Char-Broil 463230510 manual 20x1/2, Screw

Page 21

•Attach towel bar to right side shelf with 1/4-20x1/2” Screws , 7mm lock washers and 7mm flat washers (A).

7 • Hook side wall of shelf over support brackets on side of firebox (B).

•Inside firebox attach right side shelf with (3) 7mm fire washers and 1/4-20x1/2” screws, as shown (C). At back of firebox, attach the right side shelf with (1) 7mm fire washer and 1/4-20x1/2” screw, as shown (B).

•Attach right side shelf with 1/4-20 flange nuts, as shown (D).

A	Towel Bar	B
	Towel Bar	Right Side Shelf
		Right Side Shelf
		Support Bracket
		1/4-20x1/2"
	7mm	Screw
	Flat Washer
	7mm	Back of Firebox
	Lock Washer	Back of Firebox
	Lock Washer
7mm	C
Lock Washer	C
Qty. 2	7mm
	Fiber Washer
1/4-20x1/2"		D
Screw
7mm
Flat Washer
Qty. 2

1/4-20x1/2"	1/4"-20	7mm
Screw	Flange Nut	Fiber Washer
Qty. 6	Qty: 4	Qty. 4

• Attach fascia to firebox with #8-32x3/8” sheet metal screws.

#8-32x3/8"	Fascia,
#8-32x3/8"	Right Side Shelf
Sheet Metal Screws
Qty. 3

Image 21

Contents Date Purchased Estimated assembly time 35-40 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsFirst Time Use TemperatureLava Rock / Briquettes Pre-Heating Your GrillDirect Cooking Food SafetyIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures General Cleaning Why Clean?Routine Care Storing Your GrillUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Nipple has to be centered into the LP cylinder valveLeak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySDo not lean over grill while lighting Open lid during lightingSideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Flange nuts at rear Assembly20x2-3/8 Machine Screw Qty Flange Nut QtyScrews Metal TapFlange Nut Qty 20x2-3/8 Machine Screw Qty Turn assembly upside down 20x1/2 Screw Qty Right side panel removed for clarityScrew 20x1/220x1/2 Screw Back Firebox 20x1/2 Machine Screw7mm Fiber Washer Qty Sideburner Tube #8-32 wing nut#10-24x1/2 Machine Screw Qty Hinge Pin holeLeft Handle 5mm Flat Washer Qty Right Door Left Door 5mm Lock WasherBar Burner Warming Rack Leg Wire Pivot Wire Cooking Grate AA BatteryGrease Tray Heat ShieldLP Cylinder Not included Tank Retainer ScrewTroubleshooting Emergencies Possible Cause Prevention/SolutionProblem Possible Cause Prevention/Solution Problem Possible Cause Prevention/SolutionSection Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA

1/4-20x1/2"

Screw

#8-32x3/8"

Fascia,

Right Side Shelf