Char-Broil 463230510 manual 20x1/2 Screw Back Firebox, 20x1/2 Machine Screw, 7mm Fiber Washer Qty

Page 22

9	• Hook side wall of sideburner shelf over support brackets on side of firebox (A).
	• Inside firebox attach sideburner shelf with (3) 7mm fire washers and 1/4-20x1/2” screws, as shown (B).
	•	the sideburner shelf with (1) 7mm fire washer and 1/4-20x1/2” screw, as shown (A).
	•	Attach sideburner shelf with 1/4-20 flange nuts, as shown (C).
		A	7mm
		Sideburner Shelf	7mm
		Support Bracket	Fiber Washer
1/4-20x1/2"
Screw
Back of
Firebox
			1/4-20x1/2"
			Screw

C

1/4-20x1/2"	1/4"-20
Machine Screw	Flange Nut
Qty. 4	Qty: 4

7mm

Fiber Washer

Qty. 4

At back of firebox, attach

B

•Attach fascia to firebox with #8-32x3/8” sheet metal screws.

10

Fascia,

Sideburner Shelf

#8-32x3/8"

sheet metal screws

Qty. 3

22

Image 22

Contents Estimated assembly time 35-40 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionLava Rock / Briquettes TemperatureFirst Time Use Pre-Heating Your GrillIndirect Cooking Food SafetyDirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures Routine Care Why Clean?General Cleaning Storing Your GrillLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling LP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Nipple has to be centered into the LP cylinder valveConnection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF SDo not lean over grill while lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting Open lid during lightingSideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame CheckVery Important Burner tubes must reengage valve Cleaning the Burner AssemblyStoring Your Grill Turn gas OFF at control knobs and LP cylinderLimited Warranty Items Manufacturer will not PAY forParts List Key Qty DescriptionParts Diagram 20x2-3/8 Machine Screw Qty AssemblyFlange nuts at rear Flange Nut QtyMetal Tap ScrewsFlange Nut Qty 20x2-3/8 Machine Screw Qty Turn assembly upside down Right side panel removed for clarity 20x1/2 Screw Qty20x1/2 Screw20x1/2 Machine Screw 20x1/2 Screw Back Firebox7mm Fiber Washer Qty #8-32 wing nut Sideburner TubeLeft Handle Hinge Pin hole#10-24x1/2 Machine Screw Qty 5mm Flat Washer Qty Right Door Left Door 5mm Lock WasherWarming Rack Leg Wire Pivot Wire Cooking Grate AA Battery Bar BurnerLP Cylinder Not included Heat ShieldGrease Tray Tank Retainer ScrewEmergencies Possible Cause Prevention/Solution TroubleshootingProblem Problem Possible Cause Prevention/Solution Possible Cause Prevention/SolutionTroubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA