Char-Broil 463230511 manual Estimated assembly time 35-40 minutes, Date Purchased

Page 1

PRODUCT GUIDE

MODEL 463230511

IMPORTANT: Fill out the product record information below.

Serial Number

See rating label on grill for serial number.

Date Purchased

For support and to register your grill, please visit us at

www.charbroil.com

If you have questions or need assistance during assembly,

please call 1-800-241-7548.

Estimated assembly time: 35-40 minutes

The following are trademarks registered by W.C. Bradley Co. in the U.S. Patent and Trademark Office: Caldera®; Charcoal2Go®; Char-Broil®; American Gourmet®; Bandera®; Brush Hawg®; CB 940®; Char-Diamonds®; Char-Broil Charcoal/Gas®; Everybody Grills®; Grill 2 Go®; Grill 2 Go® Express®; Grill Lovers®; Infrared Grilling That’s All About U®; Keepers of the Flame®; Magneto®; New Braunfels Smoker Company®; Patio Bistro®; Patio Caddie®; Patio Kitchen®; Pro-Sear®; RED®; Quantum®; Santa Fe®; Sear and Grill®; Sierra®; Signature Series®; Sure2Burn®; The Big Easy®; U®; Wild West Tradition®; and the following marks:

®

®

The following are trademarks of W.C. Bradley Co.:America's Legendary Barbeque Company™;

Advantage Series™; Auto-Clean™;Chef Tested™; Commercial

Series™; Designer Series™;; Diamond Flame™; Double Chef™; Everybody Outside™; FastStart™; FlavorMaster™; Front Avenue™; Grill 2 Go® Advantage™; Grill 2 Go® Ice™; Hog and Yard Bird™; H20 Smoker™; Infrared. Grilling’s Juicy Little Secret™; Incredible Taste. Infallible Results™; Infrared Inside™; Let’s Grill Something Together™; Longhorn™;; Precision Flame™; Quick2Burn™; QuickSet™; Ready When You Are™; Season, Set, And Savor™; Sizzle On The Grill™; SureFire™; Torchfork™; Trentino™; Universal Grill Parts™; You Bring the Party™ TEC™ is a trademark of Tec Infrared Grills.

© 2010 Char-Broil, LLC Columbus, GA 31902

Printed in China

Assembly instructions © 2010

08/24/10 • G651-001-030801

Page 1 Page 2
Image 1
Page 1 Page 2
Contents Date Purchased Estimated assembly time 35-40 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsFirst Time Use TemperatureLava Rock / Briquettes Pre-Heating Your GrillDirect Cooking Food SafetyIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures General Cleaning Why Clean?Routine Care Storing Your GrillLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Nipple has to be centered into the LP cylinder valveConnection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySDo not lean over grill while lighting Open lid during lightingSideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderDisclaimer of Implied Warranties and Limitation of Remedies Limited WarrantyKey Qty Description Parts ListParts Diagram Flange nuts at rear Assembly20x2-3/8 Machine Screw Qty Flange Nut #8-32x3/8 Sheet Metal Screws QtyMetal Tap ScrewsFlange Nut Qty 20x2-3/8 Machine Screw Qty Turn assembly upside down 20x1/2 Screw Qty Right side panel removed for clarityScrew 20x1/220x1/2 Machine Screw 20x1/2 Screw Back Firebox7mm Fiber Washer Qty Sideburner Tube #8-32 wing nut#10-24x1/2 Machine Screw Qty Hinge Pin holeLeft Handle 5mm Flat Washer Qty Right Door Left Door 5mm Lock WasherBar Burner Warming Rack Leg Wire Pivot Wire Cooking Grate AA BatteryGrease Tray Heat ShieldLP Cylinder Not included Tank Retainer ScrewEmergencies Possible Cause Prevention/Solution TroubleshootingProblem Possible Cause Prevention/Solution Problem Possible Cause Prevention/SolutionSection Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA
Top Page Image Contents