Char-Broil 463230511 manual Storing Your Grill, Cleaning the Burner Assembly

Page 13

CAUTION

SPIDER ALERT!

SPIDER AND WEBS

INSIDE BURNER TUBE

If you notice that your grill is getting hard to light or that the flame isn’t as strong as it should be, take the time to check and clean the venturi’s.

VALVE

3.

Remove carryover tubes and burners.

4.

Detach electrode from burner.

 

NOTE: Removal/Detachment method will depend on the

 

burner configuration. See different configurations in

 

illustrations below.

5.

Carefully lift each burner up and away from valve openings.

We suggest three ways to clean the burner tubes. Use the one

easiest for you.

 

(A) Bend a stiff wire (a light weight coat hanger works well)

 

into a small hook. Run the hook through each burner

 

tube several times.

 

(B) Use a narrow bottle brush with a flexible handle (do not

 

use a brass wire brush), run the brush through each

 

burner tube several times.

 

(C) Wear eye protection: Use an air hose to force air into

 

the burner tube and out the burner ports. Check each

 

port to make sure air comes out each hole.

6.

Wire brush entire outer surface of burner to remove food

 

residue and dirt.

7.

Clean any blocked ports with a stiff wire such as an open

CONTROL PANEL

SPIDER WEBS

INSIDE VENTURI

paper clip.

8. Check burner for damage, due to normal wear and corrosion

BURNER

some holes may become enlarged. If any large cracks or

holes are found replace burner.

VERY IMPORTANT: Burner tubes must reengage valve

In some areas of the country, spiders or small insects have been known to create “flashback” problems. The spiders spin webs, build nests and lay eggs in the grill’s venturi tube(s) obstructing the flow of gas to the burner. The backed-up gas can ignite in the venturi behind the control panel. This is known as a flashback and it can damage your grill and even cause injury.

openings. See illustrations at right.

9.Attach electrode to burner.

10. Carefully replace burners.

11.Attach burners to brackets on firebox.

12.Reposition carryover tubes and attach to burners. Replace flame tamers and cooking grates.

Correct

burner-to-valve

engagement

To prevent flashbacks and ensure good performance the burner and venturi assembly should be removed from the grill and cleaned before use whenever the grill has been idle for an extended period.

Storing Your Grill

• Clean cooking grates.

• Store in dry location.

• When LP cylinder is connected to grill, store outdoors in a well-

ventilated space and out of reach of children.

• Cover grill if stored outdoors. Choose from a variety of grill

covers offered by manufacturers.

• Store grill indoors ONLY if LP cylinder is turned off and

Remove screws

Firebox

be tu yover Carr

Firebox

burner Electrode bracket

disconnected, removed from grill and stored outdoors.

• When removing grill from storage, follow “Cleaning the Burner

Assembly” instructions before starting grill.

Cleaning the Burner Assembly

Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill.

1.Turn gas OFF at control knobs and LP cylinder.

2.Remove cooking grates and flame tamers.

Firebox

tube

Carryover

Firebox burner bracket

Electrode

Pry off

electrode with

a flat blade screwdriver

13

Page 12 Page 14
Image 13
Page 12 Page 14
Contents Date Purchased Estimated assembly time 35-40 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsFirst Time Use TemperatureLava Rock / Briquettes Pre-Heating Your GrillDirect Cooking Food SafetyIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures General Cleaning Why Clean?Routine Care Storing Your GrillLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Nipple has to be centered into the LP cylinder valveConnection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySDo not lean over grill while lighting Open lid during lightingSideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderDisclaimer of Implied Warranties and Limitation of Remedies Limited WarrantyKey Qty Description Parts ListParts Diagram Flange nuts at rear Assembly20x2-3/8 Machine Screw Qty Flange Nut #8-32x3/8 Sheet Metal Screws QtyMetal Tap ScrewsFlange Nut Qty 20x2-3/8 Machine Screw Qty Turn assembly upside down 20x1/2 Screw Qty Right side panel removed for clarityScrew 20x1/220x1/2 Machine Screw 20x1/2 Screw Back Firebox7mm Fiber Washer Qty Sideburner Tube #8-32 wing nut#10-24x1/2 Machine Screw Qty Hinge Pin holeLeft Handle 5mm Flat Washer Qty Right Door Left Door 5mm Lock WasherBar Burner Warming Rack Leg Wire Pivot Wire Cooking Grate AA BatteryGrease Tray Heat ShieldLP Cylinder Not included Tank Retainer ScrewEmergencies Possible Cause Prevention/Solution TroubleshootingProblem Possible Cause Prevention/Solution Problem Possible Cause Prevention/SolutionSection Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA

463230511 specifications

The Char-Broil 463230511 is a standout gas grill that combines efficiency, performance, and user-friendly features. Designed for outdoor enthusiasts and casual cookers alike, this grill offers a versatile solution for all grilling needs.

One of its main features includes a spacious cooking area, which is essential for preparing meals for family gatherings or barbecues with friends. The primary cooking surface is complemented by a secondary warming rack, providing additional space for buns, vegetables, or sides, ensuring that all components of your meal are ready to serve at the same time.

Equipped with Char-Broil's exclusive TRU-Infrared cooking technology, the 463230511 ensures even heat distribution across the grilling surface. This innovative technology eliminates the problem of flare-ups and hot spots associated with traditional grilling methods, giving users confidence in their cooking. By using infrared heat, it helps retain more moisture in food, resulting in juicier and more flavorful meals.

The grill features four stainless steel burners, each with a powerful output that allows for efficient cooking. These burners can be easily adjusted, making it simple to reach the desired temperature. Moreover, the electronic ignition system guarantees quick and reliable starting, so you're ready to cook in no time.

Durability and ease of use are also prioritized in the design of the Char-Broil 463230511. The grill is constructed with a sturdy lid and side shelves that provide extra workspace, ideal for preparation and serving tasks. The stainless steel materials ensure a sleek appearance while also being resistant to rust and corrosion, making it a long-lasting addition to your outdoor setup.

Cleaning and maintenance are made easier thanks to the removable grease tray, which catches drippings and reduces the mess associated with grilling. Additionally, the grill's compact footprint allows it to fit neatly on patios or decks without taking up too much space.

In conclusion, the Char-Broil 463230511 gas grill is an excellent choice for anyone looking to elevate their outdoor cooking experience. With its combination of TRU-Infrared technology, ample cooking space, and durable materials, this grill promises to deliver delicious results, making every barbecue an enjoyable occasion. Whether you're a seasoned griller or just starting, this model offers the reliability and functionality you're looking for.
Top Page Image Contents