Char-Broil 463230511 manual #8-32 wing nut, Sideburner Tube

Page 23

11	• Attach sideburner bezel and valve with #8-32x3/8” SS screws. (A).
	•	Place sideburner into shelf. Make sure valve is inside sideburner tube. Attach sideburner with #8-32 wing nut (B). Hook venturi
		clip to sideburner tube and around manifold. Attach sideburner ignitor wire (C).
	• Press sideburner control knob onto valve stem (D).
	• Place grate onto sideburner shelf (E).

Sideburner

#8-32 wing nut

Sideburner Bezel

Sideburner Valve

Sideburner Control Knob

Sideburner Tube

Sideburner

Ignitor WireSideburner Valve

Venturi Clip

#8-32X3/8”	M4 Wing Nut
SS Screw	Qty. 1
Qty. 2	Sideburner Grate

Image 23

Contents Date Purchased Estimated assembly time 35-40 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsPre-Heating Your Grill TemperatureFirst Time Use Lava Rock / BriquettesRotisserie Cooking Food SafetyDirect Cooking Indirect CookingUsda Recommended Safe Minimum Internal Temperatures Storing Your Grill Why Clean?General Cleaning Routine CareLP Cylinder Filling USE and CareLP Liquefied Petroleum Gas Nipple has to be centered into the LP cylinder valve For your safetyUseDo not household cleaning agents. Damage to gas LP Cylinder Leak TestTurn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveDisclaimer of Implied Warranties and Limitation of Remedies Limited WarrantyKey Qty Description Parts ListParts Diagram #8-32x3/8 Sheet Metal Screws Qty AssemblyFlange nuts at rear 20x2-3/8 Machine Screw Qty Flange NutFlange Nut Qty 20x2-3/8 Machine Screw Qty ScrewsMetal Tap Turn assembly upside down 20x1/2 Screw Qty Right side panel removed for clarityScrew 20x1/27mm Fiber Washer Qty 20x1/2 Screw Back Firebox20x1/2 Machine Screw Sideburner Tube #8-32 wing nut5mm Flat Washer Qty Right Door Left Door 5mm Lock Washer Hinge Pin hole#10-24x1/2 Machine Screw Qty Left HandleBar Burner Warming Rack Leg Wire Pivot Wire Cooking Grate AA BatteryTank Retainer Screw Heat ShieldGrease Tray LP Cylinder Not includedProblem TroubleshootingEmergencies Possible Cause Prevention/Solution Possible Cause Prevention/Solution Problem Possible Cause Prevention/SolutionSection Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA