Char-Broil 463230511 manual Problem Possible Cause Prevention/Solution

Page 28

Troubleshooting (continued)

Problem

Possible Cause

Prevention/Solution

 

 

 

Burner(s) will not light

ELECTRONIC IGNITION:

• See Section I of Electronic Ignition System.

using ignitor.

• No spark, no ignition noise.

(See Electronic Ignition

• No spark, some ignition noise.

• See Section II of Electronic Ignition System.

Troubleshooting also)

 

• Sparks, but not at electrode or at full

• See Section III of Electronic Ignition System.

 

strength.

 

Burner(s) will not

• See “GAS ISSUES:” on previous page.

 

match light.

• Match will not reach.

• Use long-stem match (fireplace match).

 

 

• Improper method of match-lighting.

• See “Match-Lighting” section of Use and Care.

Sudden drop in gas

• Out of gas.

• Check for gas in LP cylinder.

flow or low flame.

• Excess flow valve tripped.

• Turn off knobs, wait 30 seconds and light grill. If flames are still low,

 

 

 

turn off knobs and LP cylinder valve. Disconnect regulator.

 

 

Reconnect regulator and leak-test. Turn on LP cylinder valve, wait

 

 

30 seconds and then light grill.

 

• Vapor lock at coupling nut/LP cylinder

• Turn off knobs and LP cylinder valve. Disconnect coupling nut from

 

connection.

cylinder. Reconnect and retry.

Flames blow out.

• High or gusting winds.

• Turn front of grill to face wind or increase flame height.

 

• Low on LP gas.

• Refill LP cylinder.

 

• Excess flow valve tripped.

• Refer to “Sudden drop in gas flow” above.

Flare-up.

• Grease buildup.

• Clean burners and inside of grill/firebox.

 

• Excessive fat in meat.

• Trim fat from meat before grilling.

 

• Excessive cooking temperature.

• Adjust (lower) temperature accordingly.

 

 

 

Persistent grease fire.

• Grease trapped by food buildup around

• Turn knobs to OFF. Turn gas off at LP cylinder. Leave lid in position

 

burner system.

and let fire burn out. After grill cools, remove and clean all parts.

 

 

 

Flashback...

• Burner and/or burner tubes are blocked.

• Turn knobs to OFF. Clean burner and/or burner tubes. See burner

(fire in burner tube(s)).

 

cleaning section of Use and Care.

Unable to fill LP

• Some dealers have older fill nozzles

• The worn nozzles don’t have enough “bite” to engage the valve. Try

cylinder.

with worn threads.

a second LP dealer.

One burner does not

• Grease buildup or food particles in

• Clean carry-over tube(s) with wire brush.

light from other

end(s) of carryover tube(s).

 

burner(s).

 

 

AUTO-CLEAN™

Possible Cause

Prevention/Solution

(If Equipped)

 

 

Timer does not work

ŸDead Battery

ŸReplace batteries

(Green light does not

ŸBatteries installed incorrectly.

ŸInstall batteries correctly.

flash)

ŸKnob Position did not start the Clean

ŸPush Knob in to start the clean cycle. (Green LED should begin to

 

Cycle

flash)

 

 

 

No LED’s will illuminate

ŸDead Battery

ŸReplace batteries

 

 

 

Red LED next to battery

ŸLow Battery Strength

ŸPrepare to replace batteries (NOTE: Clean cycle will operate with

symbol is illuminated

 

a weak battery.

 

 

 

28

Page 27 Page 29
Image 28
Page 27 Page 29
Contents Estimated assembly time 35-40 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionTemperature First Time UseLava Rock / Briquettes Pre-Heating Your GrillFood Safety Direct CookingIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures Why Clean? General CleaningRoutine Care Storing Your GrillLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling For your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Nipple has to be centered into the LP cylinder valveConnection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingSDo not lean over grill while lighting Open lid during lightingGeneral Grill Cleaning Sideburner Ignitor LightingSideburner Match Lighting Burner Flame CheckCleaning the Burner Assembly Storing Your GrillVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderLimited Warranty Disclaimer of Implied Warranties and Limitation of RemediesParts List Key Qty DescriptionParts Diagram Assembly Flange nuts at rear20x2-3/8 Machine Screw Qty Flange Nut #8-32x3/8 Sheet Metal Screws QtyMetal Tap ScrewsFlange Nut Qty 20x2-3/8 Machine Screw Qty Turn assembly upside down Right side panel removed for clarity 20x1/2 Screw Qty20x1/2 Screw20x1/2 Machine Screw 20x1/2 Screw Back Firebox7mm Fiber Washer Qty #8-32 wing nut Sideburner TubeHinge Pin hole #10-24x1/2 Machine Screw QtyLeft Handle 5mm Flat Washer Qty Right Door Left Door 5mm Lock WasherWarming Rack Leg Wire Pivot Wire Cooking Grate AA Battery Bar BurnerHeat Shield Grease TrayLP Cylinder Not included Tank Retainer ScrewEmergencies Possible Cause Prevention/Solution TroubleshootingProblem Problem Possible Cause Prevention/Solution Possible Cause Prevention/SolutionTroubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA

463230511 specifications

The Char-Broil 463230511 is a standout gas grill that combines efficiency, performance, and user-friendly features. Designed for outdoor enthusiasts and casual cookers alike, this grill offers a versatile solution for all grilling needs.

One of its main features includes a spacious cooking area, which is essential for preparing meals for family gatherings or barbecues with friends. The primary cooking surface is complemented by a secondary warming rack, providing additional space for buns, vegetables, or sides, ensuring that all components of your meal are ready to serve at the same time.

Equipped with Char-Broil's exclusive TRU-Infrared cooking technology, the 463230511 ensures even heat distribution across the grilling surface. This innovative technology eliminates the problem of flare-ups and hot spots associated with traditional grilling methods, giving users confidence in their cooking. By using infrared heat, it helps retain more moisture in food, resulting in juicier and more flavorful meals.

The grill features four stainless steel burners, each with a powerful output that allows for efficient cooking. These burners can be easily adjusted, making it simple to reach the desired temperature. Moreover, the electronic ignition system guarantees quick and reliable starting, so you're ready to cook in no time.

Durability and ease of use are also prioritized in the design of the Char-Broil 463230511. The grill is constructed with a sturdy lid and side shelves that provide extra workspace, ideal for preparation and serving tasks. The stainless steel materials ensure a sleek appearance while also being resistant to rust and corrosion, making it a long-lasting addition to your outdoor setup.

Cleaning and maintenance are made easier thanks to the removable grease tray, which catches drippings and reduces the mess associated with grilling. Additionally, the grill's compact footprint allows it to fit neatly on patios or decks without taking up too much space.

In conclusion, the Char-Broil 463230511 gas grill is an excellent choice for anyone looking to elevate their outdoor cooking experience. With its combination of TRU-Infrared technology, ample cooking space, and durable materials, this grill promises to deliver delicious results, making every barbecue an enjoyable occasion. Whether you're a seasoned griller or just starting, this model offers the reliability and functionality you're looking for.
Top Page Image Contents