Char-Broil 463230511 manual Screws, Metal Tap, Flange Nut Qty 20x2-3/8 Machine Screw Qty

Page 18

•Hook tank exclusion wire onto the metal taps on lower back panel, attach other ends to bottom shelf with #8-32x3/8” sheet metal

3 screws.

Lower Back Panel

#8-32x3/8"

Sheet Metal Screws

Qty. 2

Metal Tap

•Place front door brace as shown. Attach to left and right side panels with 1/4"-20x2-3/8" machine screws and 1/4”-20

4	flange nuts.

1/4"-20

Flange Nut

Qty. 4

1/4"-20x2-3/8" Machine Screw Qty. 4

Front Door Brace

Image 18

Contents Estimated assembly time 35-40 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionLava Rock / Briquettes TemperatureFirst Time Use Pre-Heating Your GrillIndirect Cooking Food SafetyDirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures Routine Care Why Clean?General Cleaning Storing Your GrillUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling LP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Nipple has to be centered into the LP cylinder valveLeak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF SDo not lean over grill while lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting Open lid during lightingSideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame CheckVery Important Burner tubes must reengage valve Cleaning the Burner AssemblyStoring Your Grill Turn gas OFF at control knobs and LP cylinderLimited Warranty Disclaimer of Implied Warranties and Limitation of Remedies Parts List Key Qty DescriptionParts Diagram 20x2-3/8 Machine Screw Qty Flange Nut AssemblyFlange nuts at rear #8-32x3/8 Sheet Metal Screws QtyScrews Metal TapFlange Nut Qty 20x2-3/8 Machine Screw Qty Turn assembly upside down Right side panel removed for clarity 20x1/2 Screw Qty20x1/2 Screw20x1/2 Screw Back Firebox 20x1/2 Machine Screw7mm Fiber Washer Qty #8-32 wing nut Sideburner TubeLeft Handle Hinge Pin hole#10-24x1/2 Machine Screw Qty 5mm Flat Washer Qty Right Door Left Door 5mm Lock WasherWarming Rack Leg Wire Pivot Wire Cooking Grate AA Battery Bar BurnerLP Cylinder Not included Heat ShieldGrease Tray Tank Retainer ScrewTroubleshooting Emergencies Possible Cause Prevention/SolutionProblem Problem Possible Cause Prevention/Solution Possible Cause Prevention/SolutionTroubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA