TROUBLESHOOTING
PROBLEM |
| CHECK and CURE | IMPORTANT | |
|
|
|
|
|
IGNITION SYSTEM | Be sure that there is gas fl ow to the burners by attempting to match light your burners. |
| ||
| If match lighting is successful, the problem lies somewhere in the ignition system and |
| ||
| will need to be checked. |
| ||
|
|
|
|
|
MAIN GRILLING BURNERS |
|
|
| If the main burner(s) still fails to ignite, make |
|
| CAUTION: Always turn the gas supply off at the tank before | sure that there is gas fl owing to the burner(s) by | |
|
| attempting to match light the burner(s). If the | ||
|
| proceeding with any troubleshooting procedures. |
| |
|
| burners will match light, then proceed with the | ||
| If, for any reason, the snap ignition fails to ignite the main grilling burner(s), repeat the | ignition checkout. | ||
| If for any reason the igniter system is still | |||
| lighting procedures described on the grill control panel. | |||
| inoperative, follow match lighting instructions. | |||
|
|
|
| |
|
| WARNING: The hood must be in the full open position any |
| |
|
| time you attempt to light your grill. Failure to open the |
| |
|
| hood could lead to delayed ignition resulting in bodily harm. |
| |
|
|
| ||
|
| After shutting off the main gas supply, remove the cook grate and heat distribution |
|
|
| plates. Turn snap igniter counter clockwise and check if the electrode is sparking to the |
| ||
| igniter tube. Try the snap igniter several times. |
| ||
|
|
|
|
|
BURNERS WITH POOR FLAME | Check to be sure burner ports, shutter, end of the burner (venturi) and orifi ce(s) are free | If you still have a poor fl ame, please contact | ||
| of any obstructions. Also, if your grill has been stored over a prolonged period of time, | dealer for futher assistance or call Customer | ||
| check to make sure no spiderwebs have been formed in the shutter end of the burner | Service | ||
| (venturi) or over orifi ces. |
| ||
| On an LP grill, if an extremely low fl ame is present, or is hard to ignite, the |
| ||
| fl |
| ||
| knobs to “high”. Wait at least 1 minute. Turn burner control knobs “OFF”, reconnect the |
| ||
| regulator to the cylinder. Turn cylinder valve on slowly. Refer to Lighting Insructions. |
| ||
|
|
|
|
|
SIDE BURNER IGNITION DOES NOT | Does burner light with a match? | If match lights burner, check igniter (see | ||
WORK. |
|
|
| Sideburner Maintenance). |
|
|
|
|
|
If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.ducane.com.
19