Weber 89962 manual Side Burner Troubleshooting

Page 19

TROUBLESHOOTING

PROBLEM

CHECK

SOLUTION

 

 

 

Burners burn with a yellow or orange flame, in

Inspect Spider/Insect screens for possible obstructions..

Clean Spider/Insect screens.. Refer to “ANNUAL

conjunction with the smell of gas.

(Blockage of holes..)

MAINTENANCE”..

 

 

 

Symptoms:

The excess flow safety device, which is part of the

To reset the excess flow safety device turn all burner

Burners do not ignite. -or- Burners have a small

barbecue to cylinder connection, may have activated..

control knobs and the cylinder valve off.. Disconnect

 

the regulator from the cylinder.. Turn burner control

flickering flame in the HI position. -or-

 

 

knobs to HI.. Wait at least 1 minute.. Turn burner control

 

 

Barbecue temperature only reaches 250° to 300° in

 

knobs to OFF.. Reconnect the regulator to the cylinder..

the HI position.

 

Turn cylinder valve on slowly.. Refer to “MAIN BURNER

 

 

IGNITION”..

 

 

 

Burner does not light, or flame is low in HI position.

Is LP fuel low or empty?

Refill LP cylinder..

 

 

 

 

Is fuel hose bent or kinked?

Straighten fuel hose..

 

 

 

Burner does not ignite when you push the igniter

Be sure that there is gas flow to the burners by

If match lighting is successful, the problem lies in the

button.

attempting to match light your burners.. Refer to “MAIN

ignition system.. Refer to “ELECTRONIC IGNITION

 

BURNER MANUAL IGNITION”..

SYSTEM OPERATIONS”..

 

 

 

 

Is there a fresh battery installed?

Verify that the battery is in good condition and installed

 

 

correctly.. Refer to “ELECTRONIC IGNITER INSPECTION”..

 

 

 

 

Are the wires connected properly to the ignitior module?

Be sure that wires are correctly inserted into terminals on

 

 

ignition box.. Refer to “ELECTRONIC IGNITION SYSTEM

 

 

OPERATIONS”..

 

 

 

 

Is there plastic wrapping around the new battery?

Remove plastic wrapping..

 

 

 

Experiencing flare-ups:

Are you preheating barbecue in the prescribed manner?

All burners on HI for 10 to 15 minutes for preheating..

m CAUTION: Do not line the slide out

 

 

Are the cooking grates, heat deflectors, and Flavorizer®

Clean thoroughly.. Refer to “CLEANING”..

grease tray with aluminum foil.

bars heavily coated with burned-on grease?

 

 

 

 

Is the slide out grease tray dirty and not allowing grease

Clean slide out grease tray..

 

to flow into catch pan?

 

 

 

 

Burner flame pattern is erratic. Flame is low when

Are burners clean?

Clean burners.. Refer to “MAINTENANCE”..

burner is on HI. Flames do not run the whole length

 

 

of the burner tube.

 

 

 

 

 

Inside of lid appears to be “peeling.” (Resembles

The inside of the lid is porcelain enamel or stainless

Clean thoroughly.. Refer to “CLEANING”..

paint peeling.)

steel, and is not painted.. It cannot “peel”.. What you are

 

 

seeing is baked on grease that has turned to carbon and

 

 

is flaking off..

 

 

THIS IS NOT A DEFECT.

 

 

 

 

Cabinet doors are not aligned.

Check the adjustment pin on the bottom of each door..

Loosen adjustment nut/s.. Slide door/s until aligned..

 

 

Tighten nut..

 

 

 

If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.

SIDE BURNER TROUBLESHOOTING

PROBLEM

CHECK

SOLUTION

 

 

 

Side Burner burns with a yellow or orange flame, in

Inspect side burner orifice alignment (Position of orifice

Loosen orifice and re-align orifice parallel to the side

conjunction with the smell of gas.

to side burner tube..)

burner tube.. Refer to “SIDE BURNER MAINTENANCE”..

 

 

 

Side Burner does not light.

Is gas supply off?

Turn supply on..

 

The excess flow safety device, which is part of the

To reset the excess flow safety device turn all burner

 

barbecue to cylinder connection, may have activated..

control knobs and the cylinder valve off.. Disconnect the

 

 

regulator from the cylinder.. Turn burner control knobs

 

 

to START/HI.. Wait at least 1 minute.. Turn burner control

 

 

knobs to OFF.. Reconnect the regulator to the cylinder..

 

 

Turn cylinder valve on slowly.. Refer to “SIDE BURNER

 

 

IGNITION”..

 

 

 

Flame is low in HI position.

Is the fuel hose bent or kinked?

Straighten hose..

 

 

 

Push button ignition does not work.

Does burner light with a match?

If match lights burner, check igniter.. Refer to “SIDE

 

 

BURNER MAINTENANCE”..

 

 

 

If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.

www.weber.com® 19

Page 18 Page 20
Image 19
Page 18 Page 20
Contents Gas Grill Liquid Propane GAS Units only Table of Contents Exploded View 320 Diagrama DE Despiece 320 VUE Eclatee Side Burner Lid Thermometer BezelShroud Cubierta Boîtier Handle Asa Poignée Warming Rack Side Burner TableWarranty General Instructions Canadian InstallationOperating Storage AND/OR Nonuse Canadian Liquid Propane Cylinder Requirements GAS InstructionsSafe Handling Tips for Liquid Propane GAS Cylinders Liquid Propane Cylinder RequirementsLiquid Propane Cylinder Important LP Cylinder InformationLeak Check Preparation Check That All Burner Valves Are OffConnect The Hose To The Cylinder Check for GAS Leaks Remove Control Knobs & Control Panel For Leak TestingRefilling the Liquid Propane Cylinder Reinstall Control PanelCheck Hose Inspection Before Using the GrillSLIDE-OUT Grease Tray and Disposable Drip PAN Electronic Igniter InspectionCrossover Ignition System Main Burner Ignition & UsageMain Burner Ignition To ExtinguishMain Burner Manual Ignition Side Burner Ignition Side Burner Ignition & UsageBurner Manual Ignition To Extinguish Side Burner Manual Ignition Flavorizer System Grilling Tips & Helpful HintsPreheating Covered Cooking Drippings and GreaseSide Burner Troubleshooting TroubleshootingCleaning MaintenanceWeber SPIDER/INSECT Screens Control Panel Removal Burner Tubes Cleaning or ReplacementBurner Tube Cleaning Burner Tube ReinstallationReplace Battery If Necessary Side Burner MaintenanceElectronic Crossover Ignition System Operations Inspection And Cleaning Of The Spider/Insect Screens Annual MaintenanceBurner Flame Pattern WEBER-STEPHEN Products LLC Barbacoa de Gas Únicamente Unidades DE GAS Propano Licuado AdvertenciasInstrucciones Sobre EL GAS ÍndiceGarantía Operación DE LA Barbacoa Instrucciones GeneralesPara Compras Hechas EN México Instalación CanadienseRequisitos de los cilindros de propano licuado Instrucciones Sobre EL GASPreparativos Para LA Búsqueda DE Fugas Información Importante Sobre EL Cilindro DE Propano LicuadoEl cilindro de propano licuado Conecte la manguera al cilindro Detección DE Fugas DE GAS Revisar Cómo Recargar EL Cilindro DE Propano LicuadoVuelva a instalar el panel de control Inspección DEL Encendedor Electrónico Antes DE Utilizar LA BarbacoaInspección DE LA Manguera Sistema De Encendido Crossover Encendido Y USO DEL Quemador PrincipalEncendido DEL Quemador Principal Para ApagarEncendido Manual DEL Quemador Principal Encendido DEL Quemador Lateral Encendido Y USO DEL Quemador LateralEncendido Manual DEL Quemador Lateral Consejos Prácticos Para Asar Resolución DE Problemas CON EL Quemador LateralProblema Verifique Solución Resolución DE ProblemasLimpieza MantenimientoMallas Weber Contra Arañas E Insectos Revisiones Para Detectar Fugas DE GAS Limpieza O Reemplazo DE LOS Tubos DEL QuemadorMantenimiento DEL Quemador Lateral Operación DEL Sistema DE Encendido CrossoverReemplace La Batería Si Fuese Necesario Patrón de la llama del quemador Mantenimiento AnualWEBER-STEPHEN Products LLC Grill a GAZ Appareils a GAZ Propane Uniquement Mises EN GardeInstructions Relatives AU GAZ Table DES MatieresGarantie Stockage ET/OU Inutilisation Installation AU CanadaGeneralites UtilisationExigences relatives à la bouteille de propane liquide Instructions Relatives AU GAZLa bouteille de propane liquide Informations Importantes Relatives a LA Bouteille DE PLPreparation DE LA Detection DES Fuites Verifiez que toutes les valves des bruleurs sont fermeesConnectez le tuyau à la bouteille de gaz Détecter les fuites Detection DES Fuites DE GAZRechargement DE LA Bouteille DE Propane Liquide Remettez en place le panneau de commandesVérifiez Inspection DU Tuyau Avant D’UTILISER LE GrillPLATEAU-EGOUTTOIR Amovible ET Egouttoir Jetable Inspection DE L’ALLUMEUR ElectroniqueDispositif D’allumage Crossover Allumage & Utilisation DU Bruleur PrincipalAllumage DU Bruleur Principal Pour EteindreAllumage Manuel DU Bruleur Principal Allumage DU Bruleur Lateral Allumage & Utilisation DU Bruleur LateralAllumage Manuel DU Bruleur Lateral Depannage DU Bruleur Lateral Astuces Pour LA GrilladeLes brûleurs brûlent avec une DepannageGrilles ANTI-ARAIGNEES/INSECTES Weber NettoyageNettoyage du tube du brûleur Nettoyage OU Remplacement DES Tubes DU BruleurRetrait du panneau de commandes Retrait du tube du brûleurUtilisation DU Dispositif D’ALLUMAGE Electronique Crossover Maintenance DU Bruleur LateralRemplacez La Pile Si Necessaire Aspect des flammes du brûleur Maintenance AnnuelleWEBER-STEPHEN Products LLC

89962 specifications

The Weber 89962 is a high-performance gas grill designed to deliver exceptional cooking results while ensuring durability and ease of use. With a focus on innovative features and advanced technologies, the Weber 89962 has become a favorite among grilling enthusiasts and outdoor cooking aficionados.

One of the standout features of the Weber 89962 is its powerful cooking system, which incorporates a total of four stainless steel burners. This allows for precise temperature control across the grilling surface, ensuring that meats are cooked evenly and to perfection. The burners are designed to provide a total output of 48,000 BTUs, making it suitable for both low and slow cooking as well as high-heat searing.

The grill also boasts an expansive cooking area, with a primary grilling space of 669 square inches and an additional warming rack that adds 198 square inches. This combination allows the user to grill multiple items simultaneously, making it ideal for family gatherings or entertaining guests. The porcelain-enameled cast iron cooking grates contribute to superior heat retention and create attractive grill marks on food.

For those who value convenience, the Weber 89962 is equipped with a built-in ignition system that ensures quick and reliable startup. The grill features a stainless steel heat diffuser that helps distribute heat evenly across the cooking surface while protecting the burners from drippings. This not only enhances flavor through reduced flare-ups but also simplifies cleanup.

Another important characteristic of the Weber 89962 is its durable construction. The grill is crafted from weather-resistant materials, ensuring it can withstand the elements and provide years of reliable service. The cart design includes enclosed storage for propane tanks and grilling accessories, keeping everything organized and easily accessible.

The grill's side tables provide additional workspace and can accommodate condiments, plates, and tools during grilling sessions. Integrated hooks allow for easy hanging of utensils, streamlining the cooking process.

Overall, the Weber 89962 combines high performance, convenience, and durability, making it an excellent choice for anyone serious about outdoor grilling. Its combination of advanced engineering and thoughtful design ensures that grilling remains a delightful experience, whether for casual weeknight meals or grand summer barbecues.
Top Page Image Contents