Weber 89962 manual Check for GAS Leaks, Remove Control Knobs & Control Panel For Leak Testing

Page 11

GAS INSTRUCTIONS

Remove Control Knobs & Control Panel For Leak Testing

1

2

You will need: Phillips screwdriver..

 

 

A) Take off the burner control knobs (1)..

 

 

B) Remove screw and washer from back of control panel with a Phillips screwdriver (2)..

 

 

C)

Remove machine screw from lower left and right side of control panel with a Phillips

 

 

 

screwdriver (3)..

3

 

D)

Tilt the back edge of the control panel up.. Carefully lift control panel up and away

 

 

 

 

from frame (4)..

 

 

E) Disconnect the igniter wires from the ignition module (5)..

 

 

F)

Replace control panel when leak check is completed.. ◆

 

 

4

CHECK FOR GAS LEAKS

mDANGER

Do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or open flames will result in a fire or explosion, which can cause serious bodily injury or death and damage to property.

Note: All factory-made connections have been thoroughly checked for gas leaks.The burners have been flame-tested.As a safety precaution however, you should recheck all fittings for leaks before using your Weber® gas barbecue. Shipping and handling may loosen or damage a gas fitting.

mWARNING: The gas connections of your gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your gas grill.

mWARNING: Perform these leak checks even if your barbecue was dealer or store assembled.

If your grill has a side burner make sure the side burner is turned off..

Turn on gas supply at source..

mWARNING: Do not ignite burners when leak checking.

You will need: A soap and water solution and a rag or brush to apply it..

A)Mix soap and water..

B)Turn on gas supply (1)..

C)Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles.. If bubbles form, or if a bubble grows, there is a leak..

If there is a leak, turn off the gas and tighten the fitting. Turn the gas back on and recheck with the soap and water solution. If leak does not stop do not use the barbecue. Contact the customer service representative in your area using the contact information on our web site. Log onto www.weber.com®.

D)When leak checking is complete, turn gas supply off at the source and rinse connections with water..

Note: Since some leak test solutions, including soap and water, may be slightly corrosive, all connections should be rinsed with water after checking for leaks.

mWARNING: You should check for gas leaks every time you disconnect and reconnect a gas fitting.

5

1

www.weber.com® 11

Page 10 Page 12
Image 11
Page 10 Page 12
Contents Gas Grill Liquid Propane GAS Units only Table of Contents Exploded View 320 Diagrama DE Despiece 320 VUE Eclatee Side Burner Lid Thermometer BezelShroud Cubierta Boîtier Handle Asa Poignée Warming Rack Side Burner TableWarranty Operating Storage AND/OR Nonuse Canadian InstallationGeneral Instructions Canadian Liquid Propane Cylinder Requirements GAS InstructionsSafe Handling Tips for Liquid Propane GAS Cylinders Liquid Propane Cylinder RequirementsLiquid Propane Cylinder Important LP Cylinder InformationLeak Check Preparation Check That All Burner Valves Are OffConnect The Hose To The Cylinder Check for GAS Leaks Remove Control Knobs & Control Panel For Leak TestingCheck Reinstall Control PanelRefilling the Liquid Propane Cylinder Hose Inspection Before Using the GrillSLIDE-OUT Grease Tray and Disposable Drip PAN Electronic Igniter InspectionCrossover Ignition System Main Burner Ignition & UsageMain Burner Ignition To ExtinguishMain Burner Manual Ignition Burner Manual Ignition To Extinguish Side Burner Ignition & UsageSide Burner Ignition Side Burner Manual Ignition Flavorizer System Grilling Tips & Helpful HintsPreheating Covered Cooking Drippings and GreaseSide Burner Troubleshooting TroubleshootingWeber SPIDER/INSECT Screens MaintenanceCleaning Control Panel Removal Burner Tubes Cleaning or ReplacementBurner Tube Cleaning Burner Tube ReinstallationElectronic Crossover Ignition System Operations Side Burner MaintenanceReplace Battery If Necessary Burner Flame Pattern Annual MaintenanceInspection And Cleaning Of The Spider/Insect Screens WEBER-STEPHEN Products LLC Barbacoa de Gas Únicamente Unidades DE GAS Propano Licuado AdvertenciasInstrucciones Sobre EL GAS ÍndiceGarantía Operación DE LA Barbacoa Instrucciones GeneralesPara Compras Hechas EN México Instalación CanadienseRequisitos de los cilindros de propano licuado Instrucciones Sobre EL GASEl cilindro de propano licuado Información Importante Sobre EL Cilindro DE Propano LicuadoPreparativos Para LA Búsqueda DE Fugas Conecte la manguera al cilindro Detección DE Fugas DE GAS Vuelva a instalar el panel de control Cómo Recargar EL Cilindro DE Propano LicuadoRevisar Inspección DE LA Manguera Antes DE Utilizar LA BarbacoaInspección DEL Encendedor Electrónico Sistema De Encendido Crossover Encendido Y USO DEL Quemador PrincipalEncendido DEL Quemador Principal Para ApagarEncendido Manual DEL Quemador Principal Encendido DEL Quemador Lateral Encendido Y USO DEL Quemador LateralEncendido Manual DEL Quemador Lateral Consejos Prácticos Para Asar Resolución DE Problemas CON EL Quemador LateralProblema Verifique Solución Resolución DE ProblemasMallas Weber Contra Arañas E Insectos MantenimientoLimpieza Revisiones Para Detectar Fugas DE GAS Limpieza O Reemplazo DE LOS Tubos DEL QuemadorReemplace La Batería Si Fuese Necesario Operación DEL Sistema DE Encendido CrossoverMantenimiento DEL Quemador Lateral Patrón de la llama del quemador Mantenimiento AnualWEBER-STEPHEN Products LLC Grill a GAZ Appareils a GAZ Propane Uniquement Mises EN GardeInstructions Relatives AU GAZ Table DES MatieresGarantie Stockage ET/OU Inutilisation Installation AU CanadaGeneralites UtilisationExigences relatives à la bouteille de propane liquide Instructions Relatives AU GAZLa bouteille de propane liquide Informations Importantes Relatives a LA Bouteille DE PLPreparation DE LA Detection DES Fuites Verifiez que toutes les valves des bruleurs sont fermeesConnectez le tuyau à la bouteille de gaz Détecter les fuites Detection DES Fuites DE GAZVérifiez Remettez en place le panneau de commandesRechargement DE LA Bouteille DE Propane Liquide Inspection DU Tuyau Avant D’UTILISER LE GrillPLATEAU-EGOUTTOIR Amovible ET Egouttoir Jetable Inspection DE L’ALLUMEUR ElectroniqueDispositif D’allumage Crossover Allumage & Utilisation DU Bruleur PrincipalAllumage DU Bruleur Principal Pour EteindreAllumage Manuel DU Bruleur Principal Allumage DU Bruleur Lateral Allumage & Utilisation DU Bruleur LateralAllumage Manuel DU Bruleur Lateral Depannage DU Bruleur Lateral Astuces Pour LA GrilladeLes brûleurs brûlent avec une DepannageGrilles ANTI-ARAIGNEES/INSECTES Weber NettoyageNettoyage du tube du brûleur Nettoyage OU Remplacement DES Tubes DU BruleurRetrait du panneau de commandes Retrait du tube du brûleurRemplacez La Pile Si Necessaire Maintenance DU Bruleur LateralUtilisation DU Dispositif D’ALLUMAGE Electronique Crossover Aspect des flammes du brûleur Maintenance AnnuelleWEBER-STEPHEN Products LLC

89962 specifications

The Weber 89962 is a high-performance gas grill designed to deliver exceptional cooking results while ensuring durability and ease of use. With a focus on innovative features and advanced technologies, the Weber 89962 has become a favorite among grilling enthusiasts and outdoor cooking aficionados.

One of the standout features of the Weber 89962 is its powerful cooking system, which incorporates a total of four stainless steel burners. This allows for precise temperature control across the grilling surface, ensuring that meats are cooked evenly and to perfection. The burners are designed to provide a total output of 48,000 BTUs, making it suitable for both low and slow cooking as well as high-heat searing.

The grill also boasts an expansive cooking area, with a primary grilling space of 669 square inches and an additional warming rack that adds 198 square inches. This combination allows the user to grill multiple items simultaneously, making it ideal for family gatherings or entertaining guests. The porcelain-enameled cast iron cooking grates contribute to superior heat retention and create attractive grill marks on food.

For those who value convenience, the Weber 89962 is equipped with a built-in ignition system that ensures quick and reliable startup. The grill features a stainless steel heat diffuser that helps distribute heat evenly across the cooking surface while protecting the burners from drippings. This not only enhances flavor through reduced flare-ups but also simplifies cleanup.

Another important characteristic of the Weber 89962 is its durable construction. The grill is crafted from weather-resistant materials, ensuring it can withstand the elements and provide years of reliable service. The cart design includes enclosed storage for propane tanks and grilling accessories, keeping everything organized and easily accessible.

The grill's side tables provide additional workspace and can accommodate condiments, plates, and tools during grilling sessions. Integrated hooks allow for easy hanging of utensils, streamlining the cooking process.

Overall, the Weber 89962 combines high performance, convenience, and durability, making it an excellent choice for anyone serious about outdoor grilling. Its combination of advanced engineering and thoughtful design ensures that grilling remains a delightful experience, whether for casual weeknight meals or grand summer barbecues.
Top Page Image Contents