Manual Operating Instructions
Hand Pump Handle
A |
Hand
Pump
Release
Valve
approximate 1/16" intervals
maximum 30 inch lbs 
minimum 
15 inch lbs
seats
(stops)
N | C |
L | |
E | O |
P | S |
O | E |
|
Release Valve
Valve Tightening Specification:
Once valve seats (stops), tighten 15 to 30 inch pounds as shown.
b
a | TU |
| RN |
| TO |
| LOCK |
To Manually Raise Platform
To Floor Level:
Note: Disregard procedures for manually moving the platform in or out if not applicable.
1.Remove pump handle from clips on side of power pack (or other storage location).
2.Place handle through pump cover access slot and into hand pump. Stroke hand pump until platform reaches floor height (see Photo C).
3.a. Pull “T” handle release cable
outward and b. turn “T” handle to lock platform into the re- leased position (see Figure 1).
4.Push platform in until it meets
floor of vehicle (if applicable).
5.Reengage the release cable mechanism by a. turning the “T” handle and b. pushing the “T” handle in fully (see Figure 2).
Note: Grasp the outer roll stop and move the platform in and out until the platform locks. You will feel the release mecha- nism engage. Read Platform
Carriage Assembly Drive Chain Reengagement Proce- dure section on opposite page!
b
B |
Open | Close |
(Down) | (Up/Stop) |
Hand Pump Handle
C |
a
TURN
TO
LOCK
|
|
|
| WA |
|
|
|
|
|
|
|
|
|
| RN |
|
|
| |
|
|
|
|
|
| IN |
|
| |
|
|
|
|
|
|
| G |
| |
| Push T- |
|
|
|
|
|
| ||
| manuallyand handle | in |
|
|
|
| |||
| lock | out |
| fully and | |||||
|
|
| tomove | ||||||
| Failurebeforeengageplatform | in | |||||||
| result | to |
|
|
| ||||
|
|
| in | lockdriving |
|
|
| ||
| platformdeployment. |
| platform | ||||||
| platform | may | |||||||
| result in unintended |
| |||||||
|
|
|
|
|
| vehicle. | |||
|
|
|
| seriousdeploymentUnintended |
| ||||
| and/or | property |
| platform | |||||
|
|
|
| may |
| ||||
Figure 1 |
| Do |
|
| bodily |
|
| ||
| not |
| damage.injury | ||||||
|
|
| remove! | 81823 | |||||
|
|
|
| ||||||
|
|
|
|
|
|
|
|
|
|
|
|
| WA |
|
|
|
|
|
|
|
|
|
| RNIN |
|
| |||
|
|
|
|
|
|
| G |
| |
Push T- |
|
|
|
|
|
|
| ||
manuallyand handle | in |
|
|
|
|
| |||
lock | out |
| fully and |
| |||||
|
| tomove |
| ||||||
Failurebeforeengageplatform | in |
| |||||||
result | to |
|
|
|
|
| |||
|
| in | lockdriving | platform |
| ||||
deploym |
|
|
|
| |||||
result in unintended |
| may |
| ||||||
platforment. |
|
| vehicle. |
| |||||
platform |
|
| |||||||
and/or |
| seriousdeploymentUnintended |
| ||||||
property |
|
| platform |
| |||||
|
|
|
| may |
| ||||
| Do |
|
| bodily |
| Figure 2 | |||
| not |
| damage.injury | ||||||
|
|
| remove! | ||||||
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
Page 17