Acnodes Q5RF SERIES user manual Do Not Destroy. Please Read Carefully And, Seer

Page 1

Q5RF SERIES

15 SEER

USER’s MANUAL & INSTALLATION INSTRUCTIONS

Single Package Heat Pump - 2 Stage, R-410A

IMPORTANT

Please read this information thoroughly and become familiar with the capabilities and use of your appliance before attempting to operate or maintain this unit. Keep this literature where you have easy access to it in the future. If a problem occurs, check the instructions and follow recommendations given. If these suggestions don’t eliminate your problem, call your Servicing Contractor.

These instructions are primarily intended to assist qualiﬁ ed individuals experienced in the proper installation of this appliance. Some local codes require licensed installation/service personnel for this type of equipment. Please read all instructions carefully before starting the installation.

DO NOT DESTROY. PLEASE READ CAREFULLY AND

KEEP IN A SAFE PLACE FOR FUTURE REFERENCE.

Image 1

Contents KEEP IN A SAFE PLACE FOR FUTURE REFERENCE DO NOT DESTROY. PLEASE READ CAREFULLY ANDQ5RF SERIES Single Package Heat Pump - 2 Stage, R-410AUSER INFORMATION INSTALLER INFORMATIONRefrigerant Charging Charts for IMPORTANT SAFETY INFORMATIONABOUT THE HEAT PUMP USER INFORMATIONOperating Instructions Figure 1. Digital ThermostatSAFETY INFORMATION INSTALLER INFORMATIONBefore You Install this Unit GENERAL INFORMATIONAir Duct System Figure 2. Drain Trap HEAT PUMP INSTALLATIONCondensate Drainage ElbowLocating & Installing the Return Air Assembly Installing Return & Supply Air FittingsMake sure the ﬁlter is readily accessible Figure 3. Minimum Unit ClearancesFigure 6. Return Air Box Locating & Installing the Supply DampersFigure 7. Supply Damper Figure 8. Power Entry Pre-ElectricalChecklistELECTRICAL CONNECTIONS Line Voltage2-SpeedOutdoor Fan Motor Select Models Overcurrent ProtectionBlower Speed Ambient Sensor MountingJumper Demand Defrost ControlMinimum Time TerminateAccessory AccessoryINDOOR THERMOSTAT SUB-BASEStart-UpProcedure STARTUP & ADJUSTMENTS Pre-StartChecklistAnti Short Cycle Timer Test Forced Defrost Mode Field TestUNIT MAINTENANCE Adjustment of Refrigerant ChargeCharging an R-410AUnit in Heating Mode Figure 11. Charging Chart for 2 ton Units Refrigerant Charging Charts forFigure 12. Charging Chart for 3 ton Units Q5RF-X24KCHARGING CHARTFigure 13. Charging Chart for 4 ton Units Refrigerant Charging Charts forFigure 14. Charging Chart for 5 ton Units Q5RF-X48KCHARGING CHARTShaded boxes indicate ﬂooded conditions Q5RF-X60KK Q5RF-X48K60HZ/SINGLE PHASE WIRING DIAGRAM¢711065«¤ 208/230V60HZ/SINGLE PHASE WIRING DIAGRAM¢711066#¤ 208/230VHigh Pressure Switch COMPONENT FUNCTIONS Low Pressure Switch¢709158D¤ Model Q5RF