Miller Electric MARK VIII-2 manual California Proposition 65 Warnings

Page 7

1-3. Additional Symbols For Installation, Operation, And Maintenance

FIRE OR EXPLOSION hazard.

D Do not install or place unit on, over, or near combustible surfaces.

DDo not install unit near flammables.

DDo not overload building wiring − be sure power supply system is properly sized, rated, and protected to handle this unit.

FALLING UNIT can cause injury.

DUse lifting eye to lift unit only, NOT running gear, gas cylinders, or any other accessories.

DUse equipment of adequate capacity to lift and support unit.

DIf using lift forks to move unit, be sure forks are long enough to extend beyond opposite side of unit.

MOVING PARTS can cause injury.

DKeep away from moving parts such as fans.

DKeep all doors, panels, covers, and guards closed and securely in place.

DHave only qualified persons remove doors, panels, covers, or guards for maintenance as necessary.

DReinstall doors, panels, covers, or guards when maintenance is finished and before re- connecting input power.

READ INSTRUCTIONS.

DRead Owner’s Manual before using or servic- ing unit.

DUse only genuine Miller/Hobart replacement parts.

OVERUSE can cause OVERHEATING

DAllow cooling period; follow rated duty cycle.

DReduce current or reduce duty cycle before starting to weld again.

DDo not block or filter airflow to unit.

STATIC (ESD) can damage PC boards.

DPut on grounded wrist strap BEFORE handling boards or parts.

DUse proper static-proof bags and boxes to store, move, or ship PC boards.

MOVING PARTS can cause injury.

DKeep away from moving parts.

DKeep away from pinch points such as drive rolls.

WELDING WIRE can cause injury.

DDo not press gun trigger until instructed to do so.

DDo not point gun toward any part of the body, other people, or any metal when threading welding wire.

H.F. RADIATION can cause interference.

DHigh-frequency (H.F.) can interfere with radio navigation, safety services, computers, and communications equipment.

DHave only qualified persons familiar with electronic equipment perform this installation.

DThe user is responsible for having a qualified electrician prompt- ly correct any interference problem resulting from the installa- tion.

DIf notified by the FCC about interference, stop using the equipment at once.

DHave the installation regularly checked and maintained.

DKeep high-frequency source doors and panels tightly shut, keep spark gaps at correct setting, and use grounding and shielding to minimize the possibility of interference.

ARC WELDING can cause interference.

DElectromagnetic energy can interfere with sensitive electronic equipment such as computers and computer-driven equipment such as robots.

DBe sure all equipment in the welding area is electromagnetically compatible.

DTo reduce possible interference, keep weld cables as short as possible, close together, and down low, such as on the floor.

DLocate welding operation 100 meters from any sensitive elec- tronic equipment.

DBe sure this welding machine is installed and grounded according to this manual.

DIf interference still occurs, the user must take extra measures such as moving the welding machine, using shielded cables, using line filters, or shielding the work area.

1-4. California Proposition 65 Warnings

YWelding or cutting equipment produces fumes or gases which contain chemicals known to the State of California to cause birth defects and, in some cases, cancer. (California Health & Safety Code Section 25249.5 et seq.)

YBattery posts, terminals and related accessories contain lead and lead compounds, chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. Wash hands after handling.

For Gasoline Engines:

YEngine exhaust contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.

For Diesel Engines:

YDiesel engine exhaust and some of its constituents are known to the State of California to cause cancer, birth defects, and other reproductive harm.

OM-218 Page 3

Image 7
Contents Description OM-218From Miller to You Table of Contents Page Electric Shock can kill Symbol UsageMarks a special safety message Arc Welding HazardsBuildup of GAS can injure or kill ARC Rays can burn eyes and skinWelding can cause fire or explosion Flying Metal can injure eyesCalifornia Proposition 65 Warnings EMF Information Principal Safety StandardsAbout Pacemakers LES Fumées ET LES GAZ peuvent être dangereux UNE Décharge Électrique peut entraîner la mortIndique un message de sécurité particulier DES Pièces Chaudes peuvent provoquer des brûlures graves LE Soudage peut provoquer unIncendie ou une explosion DES Particules Volantes peuvent blesser les yeuxDES Organes Mobiles peuvent provoquer des blessures Risque D’INCENDIE OU D’EXPLOLA Chute DE L’APPAREIL peut blesser ’EMPLOI Excessif peut SUREn ce qui concerne les stimulateurs cardiaques Principales normes de sécuritéAmperes Input at Rated Load Output, 60 Hz − SpecificationsSpecifications Volt-Ampere CurvesOverheating Duty Cycle And OverheatingFor Each Module And Total System For Main TransformerLocation And Airflow − InstallationSelecting a Location And Moving Polyweld System MovementSelecting And Preparing Weld Output Cables Dimensions, Weights And Base Mounting Hole LayoutDimensions Weight150 ft 200 ft 250 ft Weld Cable Size350 ft 400 ft 15m 30m 45 m 60 m 70 m 90 m 105 m 120 m Connecting To Weld Output Terminals Connecting Weld Output CablesSeparate Work Connections Read Safety Blocks at start of -6before proceedingStandard Module Connections Common Work Cable SizeSeparate Work Connections Common Work Parallel Module ConnectionsRemote Contactor Control Connections Optional Remote Amperage Control ReceptacleTE3 TE2 Connecting Input PowerVolts AC Duplex Receptacle Positioning Jumper LinksDisconnect Device Input Power Connec- tions Connecting Input PowerWelding Power Source Input Power Con- nections Close and secure access door on welding power sourceControls Electrical Service GuideTime-Delay − OperationHz Model Shown Amperage Adjustment ControlsPower Switch Push Buttons And Pilot Light Min 35 a Max 125 a Set Switch Set Desired Maximum AmperageOverload Protection − Maintenance & TroubleshootingRoutine Maintenance MonthsControl Fuses F3 And F4 Blank Module PanelModule Fuse Links F11 And F12 Through F81 And F82 Turn Off polyweld system, and disconnect input power TroubleshootingBefore inspecting, maintaining, or servicing OM-218 Circuit Diagram For Polyweld System − Electrical DiagramSD-082 527-C Selecting Tungsten Electrode − Selecting and Preparing Tungsten ElectrodeAmperage Range Gas Type Polarity Preparing Tungsten For DC Electrode Negative Dcen Welding Positioining The Torch − Guidelines for TIG Welding GtawTorch Movement During Welding Butt Weld And Stringer Bead Joint Lap Joint Corner Joint Positioning Torch Tungsten For Various Weld JointsMain Assembly Section a − Parts ListTP1 Main Assembly Section B CR1 194 Panel, Front Module w/Components -1Item Panel, Front Lower w/Components Panel, Front Lower w/Components -1ItemPage Your distributor also gives ServiceSupport Your distributor and/or equipment manufacturer’s To locate a Distributor or Service Agency visitMiller Electric Mfg. Co For assistance in filing or settling claims, contact