Maytag HN51240X, HN41240X manual Safety Instructions, Acaution

Page 4

Safety Instructions

_,WARNING

The water heater with draft hood installed must be

properly vented to a chimney which terminates out- doors. Never operate the water heater unless it is vented to the outdoors and has adequate air supply to avoid risks of improper operation, explosion or asphyxiation.

AWARNING

Minimum clearances between the water heater and combustible and noncombustible construction are 1'p at the sides and rear, 4" at the front, and 6" from the vent pipe. Clearance from the top of the jacket is 18" on most models. Note that a lesser dimension may be allowed on some models. Refer to the label on the

water heater adjacent to the gas control valve for all clearances.

AWARNING

Flood damage to a water heater may not be readily visible or immediately detectible. However, over a period of time a flooded water heater will create dangerous conditions which can cause DEATH, SERI-

OUS BODILY INJURY OR PROPERTY DAMAGE. Contact the Maytag dealer from whom the appli- ance was purchased or call Maytag Customer Service

at 1-800-788-8899 for an authorized servicer to replace a flooded water heater, Do not attempt to repair the unit! It must be replaced!

AWARNING

HYDROGEN GAS: Hydrogen gas can be produced in a hot water system that has not been used for a

long period of time (generally two weeks or more).

Hydrogen gas is extremely flammable and explosive. To prevent the possibility of injury under these con- ditions, we recommend the hot water faucet be opened for several minutes at the kitchen sink before any electrical appliances which are connected to the hot water system are used (such as a dish- washer or washing machine). If hydrogen gas is present, there will probably be an unusual sound similar to air escaping through the pipe as the hot water faucet is opened. There must be no smoking or open flame near the faucet at the time it is open.

_WARNING

INSULATING JACKETS; When installing an external water heater insulation jacket on a gas water heater:

•DO NOT cover the temperature-pressure relief valve.

•DO NOT put insulation over any part of the top of the gas water heater.

•DO NOT put insulation over the gas control valve or

gas control valve/burner cover, or any access areas to the burner.

•DO NOT let insulation around the gas water heater to get within 8 inches of the floor (air must get to the burner).

•DO NOT cover or remove operating instructions, and safety related warning labels and materials

affixed to the water heater.

Failure to heed this will result in the possibility of a fire or explosion.

ACAUTION

WATER HEATERS EVENTUALLY LEAK: Installation of

the water heater must be accomplished in such a manner that if the tank or any connections should leak, the flow of water will not cause damage to the structure. For this reason, it is not advisable to install the water heater in an attic or upper floor. When such locations cannot be avoided, a suitable drain pan should be installed under the water heater. Drain pans are available at your local hard- ware store. Such a drain pan must be not greater than 1½ inches deep, have a minimum length and width of at least 2 inches greater than the water heater dimensions and must be piped to an ade-

quate drain. The pan must not restrict combustion air flow. Under no circumstances is the manufactur-

er to be held liable for any water damage in con- nection with this water heater.

Page 3 Page 5
Image 4
Page 3 Page 5
Contents 1VIAYIAG Safety Instructions Awarning3Safety Instructions on Safety InstructionsPremises Safety Instructions AcautionTable of Contents Product Specifications Customer InformationAccessoriesand Tools Needed Accessories1hewater passingout may Instructions for InstallationThan normalandthisresidue,if spilledout,couldcausestaining Watertemper Outletd Mixingvalve Instructions for Installation contdReliefvalve Instructions for Installation contd Locating the New Water HeaterTopview Withoutdoor OfclosetLocating New Combustion Air and VentilationHeater Contd For Appliances Located Unconfined Spaces For /ppllances Located Confined =pacesInstructions for Installation contd IFigure3ITemperature HotterThreadedto SweatcouplingTemperature-Pressure Relief Valve ShutoffOLD PressureFilling the Water Heater DrafthoodVenttooutdoorsor Drafted ChimneyVent Pipeinstallation PerlinearfootChemical vapor corrosion of re flue and vent sys Tested before placing the appliance in operationFlexible Connector GAS Piping withGassupplypiping ManualInstallation Checklist Instructions for Operation LightingServicete chnicianForceorattemptedrepair STOPReadthesafetyinformationaboveonthislabelThepilotislit , Releaseknobanditwillpopbackup Immediatelycallyourservicetechnicianor gasInstructions for Operation contd Temperature RegulationTurn OFF the manualgascontrolvalve to the appliance Service and Maintenance OUS Bodily Injury or Property DamageBe sure Vent Erly Connected to Prevent Gasses which Could cause deadly AsphyxiationGasControl Valve & Burner Assembly Replacement Information Service and Maintenance contdBurner Cleaning Temperature-Pressure Relief Drain Valve Washer Handlassemblyand CAP WasherHousekeeping DischargepipeTroubleshooting Start Up ConditionsSMOKE/ODOR Thermal ExpansionTroubleshooting contd AIR in HOT Water Faucets AwarningOperational Conditions contd Leakage Checkpoints KCAUTIONETC Repair Parts ListETC5× Repair Parts List contd Model NumbersRepair Parts List contd Odel Numbers KEYHN41240X HN51240X HP41240X HP51240X HN41250X HN51250X Part Descripti on Part NumbersRepair Parts List contd Model Numbers KEY Part Description Part Numbers16 //i MOD EL Numbers KEY 660 0 110 Warranty0002 9164

HN41240X, HN51240X specifications

The Maytag HN51240X and HN41240X are two reliable and efficient washers, offering exceptional performance for those seeking durability and functionality in their laundry routines. These models are designed with a blend of innovative technologies and user-friendly features, making them standout options in the semi-professional segment.

The HN51240X comes equipped with a powerful motor that provides impressive wash action without compromising on efficiency. Its high-capacity drum allows users to tackle large loads easily, perfect for families or individuals with significant laundry needs. Meanwhile, the HN41240X, although slightly smaller, still boasts an impressive capacity that ensures thorough cleaning and better water usage.

Both models feature Maytag’s exclusive PowerWash cycle, which is engineered to tackle tough stains by combining extra agitation, water, and heat. This results in clothes coming out cleaner, even when dealing with heavy soil and grime. Additionally, they utilize the Advanced Moisture Sensing technology that detects moisture levels and adjusts drying time accordingly, preventing over-drying and preserving fabric quality.

The construction of the HN51240X and HN41240X emphasizes durability. Their robust design includes a stainless steel wash basket and a solid, heavy-duty frame, which not only helps reduce vibrations during operation but also ensures long-lasting performance. The machines are designed to withstand the rigors of daily use while maintaining their efficiency and effectiveness.

Another notable characteristic of these models is their energy efficiency. They are ENERGY STAR certified, meaning they meet strict energy efficiency guidelines set by the Environmental Protection Agency. This leads to lower energy bills while still delivering the performance and cleaning power users expect from a Maytag appliance.

For added convenience, both washers feature a variety of wash cycles and options, allowing users to customize their laundry experience. From delicate fabrics to bulky bedding, there is a setting suitable for every type of load. Their intuitive controls make operation straightforward, perfect for users of all experience levels.

In summary, the Maytag HN51240X and HN41240X stand out as quality washing machines that combine innovative technology with user-centric design features. They are perfect for those who value efficiency, durability, and powerful cleaning capabilities in their laundry appliances.
Top Page Image Contents