Quadra-Fire 31M-ACC-NT, 31ST-ACC Installing Pedestal Assembly, Finishing the ARS Installation

Page 22

R

3100 Wood Stove Series (ACC)

Pedestal and Ash Removal System (Cont’d)

Installing Pedestal Assembly

1.Remove screws on adapter and slide pedestal over adapter on bottom of stove. Figure 22.1.

2.Line up holes in sides of pedestal with holes in adapter.

3.Securely tighten pedestal into place.

4.Carefully stand stove up and place in desired location.

5.Slip wooden decorative strips onto pedestal edges.

Finishing the ARS Installation

1.The ARS channel is already installed on the stove. Set the grate into the ARS channel and secure with 2 bolts previously removed. Replace the 2 front cut bricks. Figure 22.2.

2.Install the ash drawer.

3.Check to make sure baffle boards and ceramic blanket are in their proper locations (see page 28).

Grate

ARS

Channel

Replace both bricks

back into firebox

NOTE: If installing a floor installation of an outside air kit on a

Figure 22.2

 

 

Step Top model with a pedestal assembly you must attach

 

 

the enclosed cover plate to the back of the stove. Other

 

 

 

 

wise you may discard this piece. See Figure 22.3.

 

 

Adapters

Ash Removel

Drawer

Cover Plate

Figure 22.3

Oak

Pedestal

Trim

Figure 22.1

Page 22

7033-277C

March 2, 2007

Image 22
Contents Pedestal Model Shown Step Top Uni-Body Model Millennium ModelFire Risk Wood Stove Series ACC Welcome to the Quadra-Fire FamilyTable of Contents Appliance Certification Listing and Code ApprovalsBTU & Efficiency Specifications Mobile Home ApprovedAsphyxiation Risk Fire SafetyService / Maintenance Tip Any such action that may cause a fire hazard Fire RiskAppliance needs to draft properly for safety Wood Stove Series ACC Negative PressureTools And Supplies Needed Wood Stove Series ACC Flue Draft ConsiderationsVenting Systems Inspect Appliance & Components and Pre-Use Check ListWood Stove Series ACC Typical Stove Systems Masonry ChimneyAppliance Dimensions 3Dimensions and ClearancesMillennium Model 34-1/4 in mm 457mm 14-15/16 19-1/16 in.379mm 484mm 33-1/8 Wood Stove Series ACC Clearances to Combustibles UL and ULC Double Wall PipeMillennium Model InstallationHearth Protection Requirements See FigureWood Stove Series ACC Step-Top Uni-Body Model Items Needed for Installation not supplied Wood Stove Series ACC Outside Air Kit InstallationFire Risk Asphyxiation Risk Wood Stove Series ACC Blower Optional Shock Risk5Chimney Requirements Venting Components Chimney SystemsInstructions ComponentsAir Clearances Solid Pack Chimney with Metal Supports as a ThimbleSolid Pack Chimney with Metal Supports as a Thimble Cont’d Installing Chimney ComponentsChimney Height / Rise and Run Wood Stove Series ACC Chimney Termination Requirements RuleMobile Home Installation Part SRV7033-041 for installation in a mobile Home7Appliance Set Up Begin installing the ARS SystemFinishing the ARS Installation Installing Pedestal AssemblyStep Top model with a pedestal assembly you must attach Installing Leg Kit Attach the 2 bottom screws of the mounting brackets toWood Stove Series ACC Door Handle Assembly Adjusting The Blower Speed ControlWood Selection & Storage Operating InstructionsBurning Process Kindling or First StageAutomatic Combustion Control ACC Air ControlsBurn Rates and Operating Efficiency Wood Stove Series ACC Building a Fire Opacity Smoke Initial cold start-up and all Burn SettingsWood Stove Series ACC Blower Operating Instructions OverfiringWood Stove Series ACC Frequently Asked Questions Issues SolutionsARS Operating and Cleaning General MaintenanceCreosote Chimney Cleaning Disposal of AshesCleaning Plated Surfaces Glass ReplacementGlass Cleaning Fire Risk Injury RiskWood Stove Series ACC Firebrick Replacement Brick Size QtyWood Stove Series ACC Baffle Removal Snap Disc Replacement BaffleRemoving Tube Channel Assembly Wood Stove Series ACC Tube Channel Assembly ReplacementReplacing Tube Channel Assembly Troubleshooting Diagnostic Question Possible Causes of Condition SolutionsDon’t get enough/any heat. What can I do about it? Reference Materials Exploded viewSizes Step Top Uni-Body Model Wood Stove Series ACC Service Parts & Accessories Item # AccessoriesItem # Service Parts Item # Service Parts Wood Stove Series ACC Service And Maintenance Log Date of Service Performed By Description of ServiceWood Stove Series ACC Homeowner’s Notes Wood Stove Series ACC Homeowner’s Notes Cont’d Lifetime Warranty Wood Stove Series ACC Warranty PolicyWood Stove Series ACC Contact Information