Quadra-Fire 31ST-ACC, 31M-ACC-GT, 31M-ACC-NT owner manual Wood Stove Series ACC Door Handle Assembly

Page 24

R

3100 Wood Stove Series (ACC)

C.Door Handle Assembly

1.Install washer on door handle shaft.

2.Slide door handle through door.

3.Install second washer(s) as shown.

4.Install key in groove.

5.Align groove in latch cam with key; slide latch cam over shaft

6.Install locknut but do not overtighten as the door handle needs to move smoothly.

7.Install spring handle turning in a counter-clockwise motion to desired location on door handle rod.

CAUTION

•Do NOT overtighten lock nut.

•Door handle needs to move smoothly.

D. Adjusting The Blower Speed Control

The blower speed control for this unit is adjusted at the factory, and normally does not require further adjustment.

NOTE: When the speed control is turned clockwise, it will click on to high speed. Continue to turn the speed control clockwise to decrease the speed. At full clockwise, the blower should blow gently, but should not stop.

1.With the appliance plugged in, turn the speed control knob to slow (full clockwise).

2.With a small screwdriver, adjust the blower speed by turning the adjustment mechanism through the hole on the side of the speed control.

3.Adjust the speed so the blower runs slowly, but does not stop. Turn clockwise to slow the blower and counterclockwise to increase the speed.

	Door Cross Section
Latch Cam	(example)
Locknut
	Spring
	Handle
	Door Handle
	Spacing
	Washers
	Square Key

Figure 24.1

Page 24

7033-277C

March 2, 2007

Image 24

Contents Step Top Uni-Body Model Millennium Model Pedestal Model ShownFire Risk Wood Stove Series ACC Welcome to the Quadra-Fire FamilyTable of Contents Listing and Code Approvals BTU & Efﬁciency SpeciﬁcationsAppliance Certiﬁcation Mobile Home ApprovedFire Safety Service / Maintenance TipAsphyxiation Risk Any such action that may cause a ﬁre hazard Fire RiskAppliance needs to draft properly for safety Wood Stove Series ACC Negative PressureWood Stove Series ACC Flue Draft Considerations Venting SystemsTools And Supplies Needed Inspect Appliance & Components and Pre-Use Check ListWood Stove Series ACC Typical Stove Systems Masonry Chimney3Dimensions and Clearances Appliance DimensionsMillennium Model 34-1/4 in mm 457mm 14-15/16 19-1/16 in.379mm 484mm 33-1/8 Wood Stove Series ACC Clearances to Combustibles UL and ULC Double Wall PipeInstallation Hearth Protection RequirementsMillennium Model See FigureWood Stove Series ACC Step-Top Uni-Body Model Wood Stove Series ACC Outside Air Kit Installation Items Needed for Installation not suppliedFire Risk Asphyxiation Risk Wood Stove Series ACC Blower Optional Shock Risk5Chimney Requirements Venting Components Chimney SystemsComponents Air ClearancesInstructions Solid Pack Chimney with Metal Supports as a ThimbleInstalling Chimney Components Solid Pack Chimney with Metal Supports as a Thimble Cont’dChimney Height / Rise and Run Wood Stove Series ACC Chimney Termination Requirements RuleMobile Home Installation Part SRV7033-041 for installation in a mobile Home7Appliance Set Up Begin installing the ARS SystemInstalling Pedestal Assembly Finishing the ARS InstallationStep Top model with a pedestal assembly you must attach Installing Leg Kit Attach the 2 bottom screws of the mounting brackets toWood Stove Series ACC Door Handle Assembly Adjusting The Blower Speed ControlOperating Instructions Burning ProcessWood Selection & Storage Kindling or First StageAutomatic Combustion Control ACC Air ControlsBurn Rates and Operating Efﬁciency Wood Stove Series ACC Building a Fire Initial cold start-up and all Burn Settings Wood Stove Series ACC Blower Operating InstructionsOpacity Smoke OverﬁringWood Stove Series ACC Frequently Asked Questions Issues SolutionsGeneral Maintenance Creosote Chimney CleaningARS Operating and Cleaning Disposal of AshesGlass Replacement Glass CleaningCleaning Plated Surfaces Fire Risk Injury RiskWood Stove Series ACC Firebrick Replacement Brick Size QtyWood Stove Series ACC Bafﬂe Removal Snap Disc Replacement BafﬂeWood Stove Series ACC Tube Channel Assembly Replacement Removing Tube Channel AssemblyReplacing Tube Channel Assembly Troubleshooting Diagnostic Question Possible Causes of Condition SolutionsDon’t get enough/any heat. What can I do about it? Reference Materials Exploded viewSizes Step Top Uni-Body Model Wood Stove Series ACC Service Parts & Accessories Item # AccessoriesItem # Service Parts Item # Service Parts Wood Stove Series ACC Service And Maintenance Log Date of Service Performed By Description of ServiceWood Stove Series ACC Homeowner’s Notes Wood Stove Series ACC Homeowner’s Notes Cont’d Lifetime Warranty Wood Stove Series ACC Warranty PolicyWood Stove Series ACC Contact Information