Field Controls MPL-B, WML-C manual Parts Listing Vestibule KIT WML C

Page 33

 

PARTS LISTING: COUNTERFLOW HORIZONTAL MODEL: WML C

 

 

 

 

Ref. No.

Description

PART NO.

31

Auxiliary Limit 60T11BOF L140º F

29198

32

Transformer

27738

33

Control Panel

30190

34

Wire Harness, Junction Box to Control

30264

35

Wire Harness, Supply

29366

36

Limit Cover, Left

30240

37

Limit Cover, Right

30195

 

 

 

 

PARTS LISTING: COUNTERFLOW HORIZONTAL DIRECT VENT MODEL: WML CB2U

 

 

 

Ref. No.

Description

PART NO.

All parts are the same as listed on the previous pages for Model WML-C except where noted below.

 

12

Oil Burner Mounting Plate Assembly

29872

 

Oil Burner Mounting Plate

29867

 

Sight Glass Cover Plate

29850

 

Sight Glass Gasket (2 per unit)

29870

 

Sight Glass

29876

13

Flue Connector Assembly 6” to 4” 90º Elbow

28952

14

Pouch Gasket (Second gasket required for Direct Vent)

2080175

15

Flue Collar Gasket (Second gasket required for Direct Vent)

21994

34

Beckett Oil Burner AFII 85

30069

 

Burner Motor 1/7 HP 3450 RPM PSC

28907

 

Beckett Clean-cut Oil Pump A2EA6520

29688

 

Solid State Ignitor 10SAY-01

28558

 

Primary Combustion Control R7184P

29649

 

Air Tube Combination FBX80HGXS

28561

 

Flame Retention Head (FB3)

28533

 

Nozzle, .60/60ºA (WML-80CB2U only)

28017

 

PARTS LISTING: VESTIBULE KIT: WML C

 

 

 

 

Ref. No.

Description

PART NO.

 

Vestibule Kit

30554

 

Door Handle

28673

 

Base Panel

29019

 

Top Panel

21437L

 

Door Panel

29022L

 

Left Side Panel

30527L

 

Right Side Panel

30528L

 

 

 

PARTS LISTING: SUB BASE FOR COMBUSTIBLE FLOOR INSTALLATION: WML C

 

 

 

Ref. No.

Description

PART NO.

 

Sub Base

06000075

33

30318 R4 9/9/2005

Page 32 Page 34
Image 33
Page 32 Page 34
Contents WML-C and MPL-B Table of Contents Introduction DOWN-FLOW InstallationHeat Loss Location of UnitAIR Conditioning Suspended InstallationChimney Venting Combustion AIRCommon Chimney Problems Optional Side Wall Venting Piping InstallationOIL Tank Electrical ConnectionsHoneywell ST9103 Dip Switch Blower Off Delay Position Time FAN Timer Board and Limit ControlDip Switch Blower Delay Position Times Off Seconds Minutes Circulating AIR BlowerOIL Burner HumidifierChecking Over-Fire Draft Furnace Installation SET- UPMaintenance and Service Routine Maintenance By Home OwnerAnnual Service By Contractor Before Lighting Operating InstructionsTo Light Unit To Shut Down UnitAF76YB Appendix A- WML-C and MPL-B Burner SET UPOIL Burner AIR Adjustment Burner ElectrodesStart UP Power CFMSpeed Model Size Weight55-1/4 19 x 18 x 20 x 20 xAppendix B Wiring Diagrams Beckett Afii Burner Wiring Diagram Riello 40F3 and F5 Burner Wiring Diagram Riello 40BF3 Burner Wiring Diagram Operation of OIL Burner Thermostat calls for heat 30318 R4 9/9/2005 Operation Returns to Idle State Recycle Timer StartsHeat Mode Action System ResponseR7184 LED Diagnostic Light TroubleshootingElectrical Shock Hazard Corrective Action Table C-3 R7184 TroubleshootingRemount control onto burner housing. Go to step Problem Possible Cause Remedy Table C4 System and General Troubleshooting Timing Final Check OUT Parts Listing Counterflow Horizontal Model WML C Parts Listing Vestibule KIT WML C 30318 R4 9/9/2005 Parts Listing Counterflow Horizontal Model MPL Flame Retention Head MPL 30318 R4 9/9/2005 If Different from Installation Contractor HOMEOWNER’S Reference TableFuel Supplier 30318 R4 9/9/2005 Tel 716 Fax 716
Top Page Image Contents