GSW 5065 manual For Your Safety, What to do if YOU Smell GAS

Page 1

FLAMMABLE VAPOUR IGNITION RESISTANT

POWER VENTED WATER HEATER

INSTALLATION AND OPERATING INSTRUCTIONS

Read and understand these instructions thoroughly before starting.

WARNING:

Improper installation, adjustment, alter- ation, service, or maintenance can cause injury or property damage. Refer to this manual. For assistance or additional infor- mation, consult a qualified installer, serv- ice agency, or the gas utility.

FOR YOUR SAFETY

•Do not store or use gasoline or other flammable vapours and liquids in the vicinity of this or any other appliance.

•Installation and service must be per- formed by a qualified installer, service agency or the gas utility.

WARNING:

If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, per- sonal injury or death.

WHAT TO DO IF YOU SMELL GAS

•Do not try to light any appliance.

•Do not touch any electrical switch; do not use any phone in your building.

•Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

•If you cannot reach your gas supplier, call the fire department.

PART NO. 63940 REV. B (06-09)

Image 1

Contents What to do if YOU Smell GAS For Your SafetyPage Table of Contents Consumer Responsibilities IntroductionFor Installations in Canada II SafetyFor Installations in the United States Safety Warning Flammable VapoursLocation Requirements Relief Valve Requirements T&PValves For Hot Water Supply Systems, Ansi Z21.22/CSA Earthquake Zones Clearances and AccessibilityGas Pressure Gas Leak TestingAir Requirements Canadian InstallationsConfined Space Air Requirements for Installations Use of Solvent Cement and Primer VentingUse only in well-ventilated areas Do not use near flame or open fireVertical Vent Terminal Installation Horizontal Vent Terminal InstallationsParts must fit well and not put stress on any sections Vent Pipe InstallationVent Pipe Connection to Blower Vent Pipe RunsRubber Coupling Connection Water Supply Piping InstallationValve Is dripping Or leaking, have a Temperature Pressure reliefLicensed plumber repair it Do not plug valveElectrical Supply Temperature and Pressure Relief ValveElectrical Code CAN/CSA C22.1, Part I Canada Or National Electrical Code Nfpa 70 U.S.AFlammable Vapour Sensor exploded view Installation Checklist QUE Faire SI Vous Sentez UNE Odeur DE GAZ Operating Instructions Instructions DE Mise EN MarcheGas Control/Thermostat When heater is ready to be put into serviceWhat to Do If You Smell Gas If You Do Not Smell GasFlammable Vapour Sensor Temperature RegulationRisk of scalding Keep the area around the heater clear Water Heater OperationUnobstructed Emergency Shut DownVI Maintenance Routine Preventative MaintenanceDraining and Flushing VII Combo Heating Replacement PartsKeep the area around the heater clear and unobstructed Combo Heating Air Handler Combo Heating Baseboard InstallationSymptom Possible Causes Corrective Action Viii Troubleshooting Guide Robertshaw 2000WDERItems not supplied with the water heater IX Parts Reference Illustration~ Certificate of Warranty ~