GSW 5065 manual IX Parts Reference Illustration, Items not supplied with the water heater

Page 28

IX) PARTS REFERENCE ILLUSTRATION

		1		2	3	4	5					27				28
		26										31				29
		25
23		24										6				30
		22
		21					6
							6

		20								REAR VIEW
		20					7


		19					8		32			33		34	35
							8

							9
		18					10	11									36
		17					12
		17															37
																	37
		16					13	14
		16					15										38
							15
															41	40	39
FRONT VIEW

1.		Vent Termination Elbow with Rodent Screen							22.		Air Switch (inside box)
2.		**Vent Pipe							23.		Junction Box
3.		**Vent Pipe Coupling (if required)							24.		Junction Box Cover
4.		**Vent Pipe Elbow (long radius)							25.		Air Tubing
5.		Limit Switch							26.		Rubber Coupling
6.		T&P Valve							27.		Gear Clamp
7.		Diptube							28.		Draft Diverter
8.		Baffle Assembly							29.		Hot Water Outlet Nipple
9.		Driptube							30.		Anode (under cap)
10.		Gas Control/Thermostat							31.		Cold Water Inlet Nipple
11.		Gas Control/Thermostat Cover							32.		Flexible Manifold Tube
12.		Drain Valve							33.		Viewport
13.		Outer Gas Door							34.		Hot Surface Igniter
14.		Manifold Door Assembly (behind outer door)							35.		Gas Orifice
15.		Floor Drain							36.		Sheet Metal Burner
16.		**Drain Pan							37.		Gas Manifold
17.		Flammable Vapour Sensor (under cover)							38.		Flame Sensor Rod
18.		Combo Heating System Return Inlet (Optional)							39.		Manifold Door Gasket
19.		Air Inlet Snorkel							40.		Manifold Door
20.		Combo Heating System Supply Outlet (Optional)							41.		Two Piece Grommet With Clip
21.		Power Cord							**		Items not supplied with the water heater.

Figure 29 Parts Reference

– 28 –

Image 28

Contents For Your Safety What to do if YOU Smell GASPage Table of Contents Introduction Consumer ResponsibilitiesII Safety For Installations in CanadaFor Installations in the United States Safety Warning Flammable VapoursLocation Requirements Relief Valve Requirements T&PValves For Hot Water Supply Systems, Ansi Z21.22/CSA Clearances and Accessibility Earthquake ZonesGas Leak Testing Gas PressureAir Requirements Canadian InstallationsConfined Space Air Requirements for Installations Venting Use of Solvent Cement and PrimerUse only in well-ventilated areas Do not use near flame or open fireHorizontal Vent Terminal Installations Vertical Vent Terminal InstallationVent Pipe Installation Parts must fit well and not put stress on any sectionsVent Pipe Connection to Blower Vent Pipe RunsRubber Coupling Connection Piping Installation Water SupplyTemperature Pressure relief Valve Is dripping Or leaking, have aLicensed plumber repair it Do not plug valveTemperature and Pressure Relief Valve Electrical SupplyElectrical Code CAN/CSA C22.1, Part I Canada Or National Electrical Code Nfpa 70 U.S.AFlammable Vapour Sensor exploded view Installation Checklist Operating Instructions Instructions DE Mise EN Marche QUE Faire SI Vous Sentez UNE Odeur DE GAZWhen heater is ready to be put into service Gas Control/ThermostatWhat to Do If You Smell Gas If You Do Not Smell GasFlammable Vapour Sensor Temperature RegulationRisk of scalding Water Heater Operation Keep the area around the heater clearUnobstructed Emergency Shut DownVI Maintenance Routine Preventative MaintenanceDraining and Flushing VII Combo Heating Replacement PartsKeep the area around the heater clear and unobstructed Installation Combo Heating Air Handler Combo Heating BaseboardViii Troubleshooting Guide Robertshaw 2000WDER Symptom Possible Causes Corrective ActionIX Parts Reference Illustration Items not supplied with the water heater~ Certificate of Warranty ~