Jenn-Air Complete Guide to Optimal Drying Techniques

Drying (on some models)

For best results, use a drying rack. A drying rack allows air to circulate evenly around the food.

The convection fan will operate during the drying procedure.

To Set Drying:

1.Open the oven door slightly. The oven door needs to be opened slightly to allow moisture to escape from the oven during the drying process.

2.Place the magnetic door spacer Part Number 8010P146-60 over the plunger switch. The spacer provides a gap between the oven frame and the oven door to allow moisture to escape.

A

A. Magnetic door spacer

3.Gently close the door until the spacer magnet makes contact with the oven door. The magnet will hold the spacer in the proper position during the drying process and allows the door to be opened at any time during drying without losing proper positioning.

IMPORTANT: If the spacer is not placed correctly, the convection fan will not operate.

4.Press CONVECT.

5.Use the right Quickset pad to scroll to DRYING.

6.Select DRYING using the left Quickset pad.

7.Use the Quickset pads to select a displayed temperature or enter a temperature with the number pads. Temperatures can be set between 100°F and 200°F (38°C and 93°C).

8.“DRYING” and the temperature will be displayed. “PREHEAT” will be displayed until the programmed temperature is reached.

9.Press CANCEL when finished drying.

Follow the Drying Guide chart for drying times.

Check foods at minimum times given. Cool foods to room temperature before testing for doneness.

DRYING GUIDE CHART

■The length of drying times vary due to water and sugar content of food, size of food pieces, amount of food being dried, humidity in the air.

■Check foods at the minimum drying time. Dry longer if necessary.

■Fruits that turn brown when exposed to air should be treated with an antioxidant. Try one of the following methods:

1.Dip fruit in a mixture of 3 tbs (44.4 mL) lemon juice to 1 qt (0.95 L) of cool water.

2.Soak fruit in a solution of 1 tsp (4.9 mL) ascorbic acid or commercial antioxidant to 1 qt (0.95 L) of cold water.

■Most fruits and vegetables dry well and retain their color when dried at 140°F (60°C). Meat and jerky should be dried between 145°F and 150°F (63°C and 65°C). For optimal flavor, dry herbs at 100°F (38°C), however, at this lower temperature expect extended drying times of up to 8 hours.

■Foods may drip during the drying process. After drying high acid or sugary foods, clean the oven bottom with soap and water. The porcelain oven finish may discolor if acidic or sugary food soils are not wiped up prior to high heat or a self-cleaning cycle.

■More than one rack of food may be dried at the same time. However, additional drying time is needed.

■Refer to other resources at your local library or call your local agricultural department service for additional information.

FOOD	VARIETIES BEST FOR	PREPARATION	APPROX. DRY	TEST FOR DONENESS
	DRYING		TIME AT 140°F	AT MINIMUM DRY TIME
			(60°C) [HOURS]**
FRUIT
Apples*	Firm varieties: Graven	Wash, peel if desired, core and	4 to 8	Pliable to crisp. Dried
	Stein, Granny Smith,	slice into ¹⁄₈" (3.0 mm) slices.		apples store best when
	Jonathan, Winesap, Rome			slightly crisp.
	Beauty, Newton
Apricots*	Blenheim/Royal most	Wash, halve, and remove pits.	18 to 24	Soft and pliable
	common. Tilton also good.
Bananas*	Firm varieties	Peel and cut into ¼" (6.0 mm)	17 to 24	Pliable to crisp
		slices.
Cherries	Lambert, Royal Ann,	Wash and remove stems. Halve	18 to 24	Pliable and leathery
	Napoleon, Van or Bing	and remove pits.
Nectarines and	Freestone varieties	Halve and remove pits. Peeling is	24 to 36	Pliable and leathery
Peaches*		optional but results in better-
		looking dried fruit.
Pears*	Bartlett	Peel, halve and core.	24 to 36	Soft and pliable

20