Burnham
RSA
manual
Recommended Smoke Pipe Arrangement and Chimney Requirements
Troubleshooting
Install
IX. Repair Parts
Error codes
Wiring of Typical Lwco
Warranty
II. Knock-Down Boiler Assembly
Adjust OIL Pressure
VIII. Service and Cleaning
Service Record
Page 19
Figure 11: Recommended Smoke Pipe Arrangement and Chimney Requirements
Figure 12: Draft Regulator Locations
19
Page 18
Page 20
Image 19
Page 18
Page 20
Contents
8143508R21-1/10 Price $3.00
RSA Series
Important Information Read Carefully
Page
Page
Table of Contents
RSA Packaged Boiler RSA170 / RSA285
Do not drop boiler. Do not bump boiler jacket against floor
Pre-Installation
Page
Installing the Jacket
II. Knock-Down Boiler Assembly
Removal of Boiler
Burner Mounting
Installation of Boiler Controls
This page is Left Intentionally Blank
III. Water Piping and Trim
Page
Page
Page
Page
Schematic Tankless Heater Piping Tankless Heater Ratings
IV. Venting
Recommended Smoke Pipe Arrangement and Chimney Requirements
General
Electrical
Rsal Wiring Less Tankless, Single Circulator
Circulator Zoned Wiring for Honeywell R8888
Zone Valve Zoned Wiring for R8889
Page
Page
Circulator Zoning with EC5000 Wiring Schematic
SchematicWiring EC5000with ZonedValve Zone19
VI. Oil Piping
Single-Pipe Installation
Two-Stage Units 3450 RPM Two Pipe Systems
Single-Stage Units 3450 RPM Two Pipe Systems
VII. System Start-Up
High Limit Controller
LED Error Codes
Display Readout
Operation
L7224 / L7248 Controller Operating Sequence
Trouble Shooting Guide
LOW Limit and Circulator Controller
Beckett Burner Carlin EZ-1HP Burner
Beckett AFG, AF, & SF Burners
Becket AFG Burner
Carlin EZ-2HP Burner
Other Adjustments
Remove GUN Assembly
Verify OIL Burner Settings Before Starting
Adjust OIL Pressure
Hints on Combustion
High Altitude Installations
Verify High Limit Operation
Test Controls
Use Part Number 6183505 for the following models
Clean the Firetubes
VIII. Service and Cleaning
Avoid Breathing Fiber Particulates and Dust
IX. Repair Parts
Fogire 28 Assembled Boiler
Description Part Number
RSA85-135 Bare Boiler Repair Parts
‘A’
RSA170-285 Boiler Repair Parts
Jacket Top Panel Assembly
Beckett Burner Parts List for RSA Series Steel Boilers
Ordering Information for Quality Replacement Parts
AF60XO AF60XP SF60FY
Beckett AF and SF Model Burners
Low Water Cut Off Lwco
Wiring of Typical Lwco
Lwco Location
Service Record
Limited Warranty
Top
Page
Image
Contents