Burnham RSA manual Use Part Number 6183505 for the following models

Page 37

INSTALLATION INSTRUCTIONS FOR SHIELD REQUIRED FOR COMBUSTIBLE FLOOR

This shield for combustible floors is intended for use only with the following Burnham oil-fired boilers: Use Part Number 6183504 for the following models:

RSA85 RSA110 RSA125 RSA135

ADDS 4-3/16” TO BOILER HEIGHT

Use Part Number 6183505 for the following models:

RSA170 RSA195 RSA240 RSA285

ADDS 5-3/8” TO BOILER HEIGHT

1)Place shield on combustible floor with “TOP” surface upward and “FRONT” surface directly below the expected position of the oil burner.

2)Locate shield such that clearances to combustible walls are as indicated in Figure 26. These dimensions will assure that the boiler jacket will be at least 18” from the side and rear walls and 48” from the front wall, as required by ANSI/NFPA 31.

3)Fasten shield to combustible floor to keep shield from shifting position during setting of boiler.

4)Set boiler squarely on top of shield such that base plate of boiler rests flat on top surface of shield and does not over-hang shield on any side. Confirm clearance to combustible walls. Refer to Figure 2.

5)Do not enclose boiler (including shield) on all four sides. Boiler may be enclosed on any three sides while maintaining minimum clearances shown in Figure 2 for each of those three sides.

Figure 26

37

Page 36 Page 38
Image 37
Page 36 Page 38
Contents 8143508R21-1/10 Price $3.00 RSA SeriesImportant Information Read Carefully Page Page Table of Contents RSA Packaged Boiler RSA170 / RSA285 Do not drop boiler. Do not bump boiler jacket against floor Pre-InstallationPage Installing the Jacket II. Knock-Down Boiler AssemblyRemoval of Boiler Burner Mounting Installation of Boiler ControlsThis page is Left Intentionally Blank III. Water Piping and Trim Page Page Page Page Schematic Tankless Heater Piping Tankless Heater Ratings IV. Venting Recommended Smoke Pipe Arrangement and Chimney Requirements General ElectricalRsal Wiring Less Tankless, Single Circulator Circulator Zoned Wiring for Honeywell R8888 Zone Valve Zoned Wiring for R8889 Page Page Circulator Zoning with EC5000 Wiring Schematic SchematicWiring EC5000with ZonedValve Zone19 VI. Oil Piping Single-Pipe InstallationTwo-Stage Units 3450 RPM Two Pipe Systems Single-Stage Units 3450 RPM Two Pipe SystemsVII. System Start-Up Display Readout LED Error CodesOperation High Limit ControllerL7224 / L7248 Controller Operating Sequence Trouble Shooting GuideLOW Limit and Circulator Controller Becket AFG Burner Beckett AFG, AF, & SF BurnersCarlin EZ-2HP Burner Beckett Burner Carlin EZ-1HP BurnerVerify OIL Burner Settings Before Starting Remove GUN AssemblyAdjust OIL Pressure Other AdjustmentsHints on Combustion High Altitude InstallationsVerify High Limit Operation Test ControlsUse Part Number 6183505 for the following models Clean the Firetubes VIII. Service and CleaningAvoid Breathing Fiber Particulates and Dust IX. Repair Parts Fogire 28 Assembled Boiler Description Part NumberRSA85-135 Bare Boiler Repair Parts ‘A’ RSA170-285 Boiler Repair Parts Jacket Top Panel Assembly Beckett Burner Parts List for RSA Series Steel Boilers Ordering Information for Quality Replacement Parts AF60XO AF60XP SF60FY Beckett AF and SF Model Burners Low Water Cut Off Lwco Wiring of Typical LwcoLwco Location Service Record Limited Warranty

RSA specifications

Burnham RSA is a prominent figure in the renewable energy sector, specializing in the development and management of renewable energy projects across various scales. The company has established a strong reputation for its commitment to sustainability and innovation, embracing advanced technologies and methodologies to maximize energy efficiency and minimize environmental impact.

At the heart of Burnham RSA's operations lies a diverse portfolio of renewable energy sources, including solar, wind, and biomass. The company's flagship projects often showcase cutting-edge solar photovoltaic (PV) technology, which effectively converts sunlight into electricity. By utilizing high-efficiency solar panels, Burnham RSA can ensure maximum energy generation, even in less-than-ideal weather conditions.

Wind energy is another critical component of Burnham RSA's strategy. The deployment of state-of-the-art wind turbines at strategic locations allows for optimal harnessing of wind energy. These turbines are equipped with advanced control systems that optimize their performance by adjusting their orientation and blade pitch to maximize energy capture based on real-time wind conditions.

In addition to solar and wind, Burnham RSA is actively exploring biomass energy solutions, which involve converting organic materials into usable energy. This approach not only provides a renewable energy source but also contributes to waste reduction, as agricultural and forestry residues can be repurposed to generate power.

Burnham RSA places a strong emphasis on sustainability, ensuring that all projects are designed with environmental considerations at the forefront. The company adheres to rigorous standards for environmental impact assessments and works closely with local communities to promote awareness and education about renewable energy benefits.

Smart grid technology is another area where Burnham RSA excels. By implementing advanced grid management systems and energy storage solutions, the company enhances the reliability and efficiency of renewable energy distribution. These systems allow for better integration of various energy sources, ensuring a stable energy supply even during peak demand periods.

Furthermore, Burnham RSA is committed to continuous innovation, investing in research and development to improve existing technologies and explore new avenues for energy production. This proactive approach not only fosters growth within the company but also contributes positively to the broader renewable energy landscape.

In summary, Burnham RSA stands out in the renewable energy sector through its comprehensive use of solar, wind, and biomass technologies, commitment to sustainability, and focus on innovation. With its advanced systems and community engagement efforts, Burnham RSA is poised to play a significant role in shaping the future of renewable energy.
Top Page Image Contents