Burnham RSA manual AF60XO AF60XP SF60FY

Page 48

BECKETT BURNER PARTS LIST FOR RSA SERIES STEEL BOILERS

FOR REPLACEMENT OIL BURNER PARTS, CONTACT YOUR WHOLESALER OR THE BURNER MANUFACTURER:

R. W. BECKETT CORP.

38251 CENTER RIDGE RD. P. O. BOX 1289 ELYRIA, OHIO 44036

1-800-645-2876

	Boiler Model	RSA170	RSA195	RSA240/285
	Burner Model	AF	AF	SF
	Air Tube Combination	AF60XO	AF60XP	SF60FY
	Spec. No.	BCB114	BCB116	BCB211
1)	Air Band	3492	3492	3492
	Air Band Nut	4150	4150	460
	Air Band Screw	4198	4198	4219
2)	Air Shutter	3494	3494	3215
	Air Shutter Screw	4198	4198	493
6)	Blower	2459	2459	2288
7)	Bulkhead Fitting	3488	3488	3488
8)	Bulkhead Fitting Locknut	3666	3666	3666
9)	Connector Tube Assembly	5636	5636	5636
10)	Coupling	2454	2454	2433
11)	Electrode Clamp	149	149	149
	Electrode Clamp Screw	4219	4219	4219
12)	Electrode Insulator Assembly	EA21502	EA21502	EA21502
15)	Spider Spacer Assembly	5653	5653	5653
16)	Escutcheon Plate	3493	3493	3493
18)	Flange and Air Tube Assembly	58115	58115	58115
	Gasket	3616	3616	3616
19)	Head	360012	360022	5434
	Head Screws	4221	4221	4221
	Hole Plug	2139	2139	2139
20)	Housing Assembly w/Inlet Bell	5624	5624	53485
21)	Motor	2456	2456	2364
22)	Nozzle Adapter	213	213	213
23)	Nozzle Line Electrode Assembly	NC6048	NC6058	NC6048
25)	Pump (Includes Valve)	21844	21844	21844
27)	Static Plate	3383	3383	3383
28)	Ignitor	51824U	51824U	51824U
29)	Ignitor Hinge Screw	4217	4217	4217
30)	Ignitor Holding Screw	4198	4198	4198
31)	Ignitor Gasket Kit	51304	51304	51304
21)	Wire Guard	3345	3345	3345

48

Image 48

Contents RSA Series 8143508R21-1/10 Price $3.00Important Information Read Carefully Page Page Table of Contents RSA Packaged Boiler RSA170 / RSA285 Pre-Installation Do not drop boiler. Do not bump boiler jacket against floorPage II. Knock-Down Boiler Assembly Installing the JacketRemoval of Boiler Installation of Boiler Controls Burner MountingThis page is Left Intentionally Blank III. Water Piping and Trim Page Page Page Page Schematic Tankless Heater Piping Tankless Heater Ratings IV. Venting Recommended Smoke Pipe Arrangement and Chimney Requirements Electrical GeneralRsal Wiring Less Tankless, Single Circulator Circulator Zoned Wiring for Honeywell R8888 Zone Valve Zoned Wiring for R8889 Page Page Circulator Zoning with EC5000 Wiring Schematic SchematicWiring EC5000with ZonedValve Zone19 Single-Pipe Installation VI. Oil PipingSingle-Stage Units 3450 RPM Two Pipe Systems Two-Stage Units 3450 RPM Two Pipe SystemsVII. System Start-Up LED Error Codes Display ReadoutOperation High Limit ControllerTrouble Shooting Guide L7224 / L7248 Controller Operating SequenceLOW Limit and Circulator Controller Beckett AFG, AF, & SF Burners Becket AFG BurnerCarlin EZ-2HP Burner Beckett Burner Carlin EZ-1HP BurnerRemove GUN Assembly Verify OIL Burner Settings Before StartingAdjust OIL Pressure Other AdjustmentsHigh Altitude Installations Hints on CombustionTest Controls Verify High Limit OperationUse Part Number 6183505 for the following models VIII. Service and Cleaning Clean the FiretubesAvoid Breathing Fiber Particulates and Dust IX. Repair Parts Description Part Number Fogire 28 Assembled BoilerRSA85-135 Bare Boiler Repair Parts ‘A’ RSA170-285 Boiler Repair Parts Jacket Top Panel Assembly Beckett Burner Parts List for RSA Series Steel Boilers Ordering Information for Quality Replacement Parts AF60XO AF60XP SF60FY Beckett AF and SF Model Burners Wiring of Typical Lwco Low Water Cut Off LwcoLwco Location Service Record Limited Warranty