Henny Penny OE/OG 301/302/303 manual Odel Foaming Boil, At end of frying cycle, drain, Filtering

Page 5

odel

Foaming	or	boil-	Water	in		At end of frying cycle, drain	shortening		and clean frypot.
ing over	of		shortening			Add fresh shortening.
shortening.			Improper		or bad	Use recommended shortening.
			Improper		or bad	Use recommended shortening.
			shortening
			Improper			Refer to the procedure covering		filtering	the shortening.
			filtering
			Improper		rinsing	@Clean and rinse the frypot.	Then	dry thoroughly.
			after	cleaning the
			fryer
Shortening		will	Drain	valve		8 Open valve force cleaning brush through			drain opening.
not drain	from		clogged		with
frypot			crumbs

Drain valve will not open by turn- ing handle

a Replace cotler pins in in valve capling.

Filter	motor rum	Filter	valve not		Open filter		valve.
but pumps		open
shortening slowly		Pump clogged			Remove and clean pump per Section 6-15.
		Pump clogged			Remove and clean pump per Section 6-15.
		Filter	line	con-	Tighten	all	filter line connections.
		nection loose
		Solidified			Clear all	filter		lines of solidified shortening.
		shortening		in
		lines
Filter	switch ON	Defective		switch	Check/replace switch per Section 6-15.
motor	does not	Defective		motor	Check/replace motor per Section 6-15.
run		Defective		motor	Check/replace motor per Section 6-15.
		Motor	thermal		Reset thermal			switch per Section 3-7.
		protector		tripped
.“Y Motor	hums but	Clogged lines or			Remove and clean pump and lines.
Lb,&> will not pump		pump

Replace pump seal, rotor and rollers per 6-15.

5-5

Image 5

Contents

ElO, E15, E41, E50, E51, and E53 El5 Drain Switch En turn switc Per -5, orLimit ElO Faulty Drain With switch No power to Check fuse on PC boardSwitch BoardTrol switch Line Pilot will not Faulty therm0Switch terminals with ohmmeter Not Lit LightBoard if heat indicator Wire connectionTemperature LES NG Heating Low or improperRinsing @Clean and rinse the frypot Refer to the procedure coveringAfter Cleaning Fryer Shortening Will Odel Foaming Boil