Hoshizaki DKM-500BAH service manual Circulate, Wash

Page 18

b)CIRCULATE

When the service switch is active and placed in the CIRCULATE position, power is supplied to the pump only. This operation can be used to circulate cleaner for extended periods of time over the outside surface of the evaporator.

c)WASH

This model utilizes a solenoid operated cleaning (bypass) valve. When the service switch is active and placed in the WASH position, power is supplied to the pump and the cleaning valve. This cleans both the inside and outside of the evaporator plate assembly.

18

Image 18 Contents
DKM-500BAH Hoshizaki AMERICA, INC Contents Page Specifications DKM-500BAHII. General Information Construction DKM-500BAHSequence of Operation DKM-500BAH Sequence Flow Chart and Component Operation CycleControl Board Control Products E Control Board Control Board LayoutControl Board Low Water Safety Harvest Backup Timer and Freeze TimerHigh Temperature Safety Maximum Water Supply Period 6 minutesLED Lights and Audible Alarm Safeties PM, SR, DVControls and Adjustments Default Dip Switch SettingsHarvest Control Thermistor Harvest Timer dip switch 1 Pump-Out Timer dip switch 3Pump-Out Frequency Control dip switch 5 Freeze Timer dip switch 9Bin Control Machine Will Not Start Bin Control TroubleshootingControl Board Check Procedure Machine Will Not Shut OffControl Switch SwitchesControl Board Replacement Service SwitchCirculate WashDKM-500BAH Wiring Diagram Timing Chart Page Performance Data 110IV. Service Diagnosis Minute Diagnostic Procedure Diagnostic Charts Ice MakingNo Ice Production Problem Possible Cause Remedy Problem Possible Cause Remedy Evaporator is Frozen Up Low Ice Production Abnormal IceOther DispensingProblem Possible Cause Remedy Refrigerant Recovery Removal and Replacement of ComponentsService for Refrigerant Lines Evacuation and Recharge R-404ARemoval and Replacement of Compressor BrazingRemoval and Replacement of Drier Removal and Replacement of Expansion Valve Removal and Replacement of Hot Gas ValveRemoval and Replacement of Evaporator Removal and Replacement of Condenser Removal and Replacement of Thermistor Removal and Replacement of Fan MotorRemoval and Replacement of Inlet Water Valve Removal and Replacement of Pump MotorRemoval and Replacement of Spray Tubes Removal and Replacement of Gear MotorRemoval and Replacement of Dispense Switch Removal and Replacement of SolenoidVI. Cleaning and Maintenance Instructions Cleaning InstructionsCleaning Procedure Icemaker Sanitizing Procedure Icemaker Cleaning Procedure Bin Sanitizing Procedure BinExterior Panels Maintenance InstructionsPreparing the Icemaker for Long Storage Air Filters