Manitowoc Ice Q130 manual Operation, Component Identification

Page 17

Section 3 Operation

Component Identification

ICE THICKNESS

PROBE

DISTRIBUTION

TUBE

EVAPORATOR (Q210/Q270 SHOWN)

ICE DAMPER

WATER PUMP

BIN SWITCH

WATER TROUGH

ON/OFF/WASH

TOGGLE

SWITCH

ON/OFF/WASH

TOGGLE

SWITCH

FLOAT VALVE

SIPHON CAP

CONDENSER AIR

FILTER

CONDENSER AIR

FILTER

COMPRESSOR COMPARTMENT

COMPRESSOR COMPARTMENTACCESS SCREWS

ACCESS SCREWS

Part Number 000001130 12/08

3-1

Image 17

Contents Q130/Q210/Q270 UnderCounter Model Ice Machines Procedural Notices Safety NoticesRead These Before Proceeding Personal Injury PotentialTable of Contents Section Before Calling for Service Table of Contents Section OperationSection Maintenance Model Numbers AccessoriesSection General Information Q270 Models General Information Section Model/Serial Number LocationModel/Serial Number Location Ice Machine Model Number Serial NumberAuthorized Warranty Service Commercial Warranty Coverage GeneralService Calls GeneralGeneral Information Section Ice Machine Dimensions Section Installation InstructionsGeneral Q130/Q210 ICE MachinesSeries Heat of Rejection Ice Machine Air Conditioning Peak Installation Instructions Section Location of Ice MachineIce Machine Heat of Rejection Checking Ice Machine Level Section Installation Instructions Leveling the Ice MachineInstallation Instructions Section Electrical Service Water Supply Section Installation Instructions Water Service/DrainsWater Inlet Lines Drain ConnectionsTypical Water Supply Drain Installation Personal Injury Potential Installation Instructions Section Installation Checklist Component Identification OperationInitial START-UP or START-UP After Automatic SHUT-OFF Operation Section Ice Making Sequence of OperationSection Operation Energized Parts Chart Siphon System Operation Section Operational ChecksSiphon System Check Water Float Valve CheckWater Level Check Section OperationICE Bridge Thickness Check Ice Thickness CheckOperation Section Cleaning and Sanitizing Procedure Section MaintenanceInterior Cleaning and Sanitizing Maintenance Section Float Valve Removal Q130 ModelsQ130 Water Distribution Tube Removal Remove the Water Trough Remove the ice damper InstallationQ130 Q210/Q270Remove the Bin Door Solution Type Water Mixed withSolution Type Water Mixed With Sanitizer Model Amount of Sanitizer Exterior CleaningICE Machine Inspection Water-Cooled Condenser Water Regulating Valve Cleaning the CondenserAir-Cooled Condenser SELF-CONTAINED AIR-COOLED ICE Machines Maintenance Section Removal From Service WinterizationWATER-COOLED ICE Machines Pry Open the Water Regulating ValveThis page Intentionally Left Blank Maintenance Section Problem Possible Cause To Correct Section Before Calling for ServiceChecklist Safety Limit Feature Before Calling for Service SectionSafety Limit Stand-By Mode Safety LimitsDetermining Which Safety Limit Stopped The Ice Machine Safety Limit NotesPossible Cause Check/Correct Safety Limit #1Safety Limit #2 This page Intentionally Left Blank