SECTION 1: SPECIFICATION INFORMATION
ELECTRICAL REQUIREMENTS
NOTE: Typical Electrical Circuit is based upon (1) 125% of the full amperage load of the machine and (2) typical fixed-trip circuit breaker sizes as listed in the NEC 2002 Edition. Local codes may require more stringent protection than what is displayed here. Always verify with your electrical service contractor that your circuit protection is ade- quate and meets all applicable national and local codes. These numbers are provided in this manual simply for ref- erence and may change without notice at any given time.
TEMPSTAR: | | | | | TEMPSTAR LT/TEMPSTAR NB: | | |
| | | RINSE | | TYPICAL | | | | RINSE | | TYPICAL |
| | | HEATER | TOTAL ELECTRICAL | | | | HEATER | TOTAL ELECTRICAL |
VOLTS | PH | HZ | RATINGS | AMPS | CIRCUIT | VOLTS | PH | HZ | RATINGS | AMPS | CIRCUIT |
208 | 1 | 50 | 12KW@240V | 71 A | 90 AMP | 208 | 1 | 50 | N/A | 28 A | 35 AMP |
208 | 1 | 50 | 14KW@240V | 78 A | 100 AMP | 230 | 1 | 50 | N/A | 30 A | 40 AMP |
230 | 1 | 50 | 12KW@240V | 78 A | 100 AMP | | | | | | |
230 | 1 | 50 | 14KW@240V | 86 A | 110 AMP | 208 | 3 | 50 | N/A | 20 A | 25 AMP |
| | | | | | 230 | 3 | 50 | N/A | 21 A | 30 AMP |
208 | 3 | 50 | 12KW@240V | 45 A | 60 AMP | 380 | 3 | 50 | N/A | 10 A | 15 AMP |
208 | 3 | 50 | 14KW@240V | 49 A | 70 AMP | 415 | 3 | 50 | N/A | 10 A | 15 AMP |
230 | 3 | 50 | 12KW@240V | 48 A | 60 AMP | 440 | 3 | 50 | N/A | 8 A | 15 AMP |
230 | 3 | 50 | 14KW@240V | 53 A | 70 AMP | | | | | | |
380 | 3 | 50 | 12KW@380V | 29 A | 40 AMP | 208 | 1 | 60 | N/A | 26 A | 35 AMP |
380* | 3 | 50 | 14KW@208V | 34 A | 45 AMP | 230 | 1 | 60 | N/A | 28 A | 35 AMP |
415 | 3 | 50 | 12KW@415V | 26 A | 35 AMP | | | | | | |
415 | 3 | 50 | 14KW@415V | 29 A | 40 AMP | 208 | 3 | 60 | N/A | 18 A | 25 AMP |
440 | 3 | 50 | 12KW@460V | 21 A | 30 AMP | 230 | 3 | 60 | N/A | 28 A | 35 AMP |
440 | 3 | 50 | 14KW@460V | 25 A | 35 AMP | 460 | 3 | 60 | N/A | 8 A | 15 AMP |
208 | 1 | 60 | 12KW@240V | 69 A | 90 AMP | | | | | | |
208 | 1 | 60 | 14KW@240V | 76 A | 100 AMP | TEMPSTAR S: | | | | |
230 | 1 | 60 | 12KW@240V | 76 A | 100AMP | | | | RINSE | | TYPICAL |
230 | 1 | 60 | 14KW@240V | 84 A | 110 AMP | | | | HEATER | TOTAL ELECTRICAL |
| | | | | | VOLTS | PH | HZ | RATINGS | AMPS | CIRCUIT |
208 | 3 | 60 | 12KW@240V | 43 A | 60 AMP | 208 | 1 | 60 | N/A | 6 A | 15 AMP |
208 | 3 | 60 | 14KW@240V | 47 A | 60 AMP | 230 | 1 | 60 | N/A | 6 A | 15 AMP |
230 | 3 | 60 | 12KW@240V | 46 A | 60 AMP | | | | | | |
230 | 3 | 60 | 14KW@240V | 51 A | 70 AMP | 208 | 3 | 60 | N/A | 6 A | 15 AMP |
460 | 3 | 60 | 12KW@480V | 22 A | 30 AMP | 230 | 3 | 60 | N/A | 6 A | 15 AMP |
460 | 3 | 60 | 14KW@480V | 25 A | 35 AMP | | | | | | |
* This model is wired in a wye configuration for the heaters.
Tempstar LT/NB/S Technical Manual 7610-003-61-42 B
Issued: 10-08-2008 Revised: N/A
Jackson MSC, LLC. P.O. BOX 1060 HWY E
INSTALLATION/OPERATION Technical Manual
Tempstar Tempstar LT Tempstar NB
Tempstar S
Page
ONE Year Limited Parts & Labor Warranty
Manufacturers Warranty
Stop Pare Arret
Removed NSF Rating from steam heated unit
Released to production
Added new NSF rating
Nomenclature for the Models Covered in this Manual
Model Serial No Installation Date Service Rep. Name Phone No
Table of Contents
VII
VI.A
VI.C
Section Specification Information
Specification Information
Rinse Typical
This model is wired in a wye configuration for the heaters
Volts Ratings Amps Circuit
Tempstar S
Drain 1 1/2 NPT 8 12.4 cm 25 1/4 64.1 cm
Dimensions TEMPSTAR/NB/LT/S TOP Mounted Control BOX
Corner Installation
Table Dimensions
Section INSTALLATION/OPERATION Instructions
Side and from front to back before making any connections
INSTALLATION/OPERATION Instructions
Installation Instructions
Ground Lug
Operation Instructions
Detergent Control
False panel positioned in unit
False Panel Installation
Section Preventative Maintenance
Preventative Maintenance
Preventative Maintenance
Section Troubleshooting Section
Common Problems
Troubleshooting
Problem Dishes are not coming clean
Problem Doors will not close completely
Problem Water leaks at the wash pump
Problem Will not rinse during autocycle
Section Parts Section
Parts Section
TOP Mounted Control BOX Assembly with Universal Timer
Relay, 415V, 3PH, 5 Wire Only
Timer Bracket
Switch, 8 Button
Timer, Universal
Hood Assembly Bolted Single Support Design
3e3d
Cantilever ARM/DOOR Assemblies
10, 11
19, 11
Door, Right Side Complete Assembly
Yoke Assembly
Connector, Cantilever Arm
Magnet, Reed Switch
TUB Assembly
Tub Weldment
Rack Assembly
Pump Support Bracket Assembly
Connector, 1/2 90
Steam TUB Assembly
Connector, 1/2 90 Deg
Front Panel
Frame Assembly
Rinse Tank Assembly
Washer, 1/4 I.D
Rinse Tank and Round Flange Heater Assembly
Washer, 1/4 S/S Flat
Nut, Hex, 1/4-20-18
05700-002-08-62 05700-002-08-52
Coil Assembly
Incoming Steam Plumbing Assemblies
Wash Motors
Model Volts Phase Wash Motor Assembly
Other parts not shown
Motor & Pump Assembly
Wash HEATERS/RINSE Heaters
Model Volts Phase
Tempstar 208 04540-003-58-27 04540-003-58-28 230
Rinse Heaters Round Flanged Heater
Model Volts
Tube Length Chart Item # Length Inches
Tempstar Incoming PLUMBING/OUTLET Plumbing Assembly
Complete Assembly
Complete assembly 05700-003-60-75
Wprk KIT Option
Tempstar LT & Tempstar NB Incoming Plumbing Assembly
Coil & Housing only
Solenoid Valve & 1/2 NPT Vacuum Breaker Repair Parts Kits
Complete Vacuum Breaker Assembly, 1/2 NPT
Complete 110 Volt Solenoid Valve Assembly, 1/2
Rinse Injector Gasket Per machine 05330-111-42-81
Wash & Rinse ARM/MANIFOLD Assemblies
1811
Lockwasher,3/8
Bearing Assembly
Rinse Manifold Assembly
Upper Manifold
380V Transformer 05950-111-64-17
Other Safety Door Interlock SDI components not shown
Transformer
05925-111-64-18
False panel positioned in unit
Pump & Motor Assembly, S/S
Switch, Door, Magnetic Reed
Bearing Assembly, Wash Arm
Switch, Power Push Button
To Cold Water Supply
Drain Quench Assembly
To Dishmachine Drain
Tee, 1-1/2 x 1-1/2 x 1-1/2 Reducer, 1-1/2 to 1/2
Electrical Schematics For TOP Mount Units
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics For Options
SDI Option
Exhaust FAN HOOKUP/DRAIN Quench Options
Section Jackson Maintenance Repair Centers
Alabama to Florida
Jackson Maintenance & Repair Centers
Florida to Maryland
Service CO
Maryland to NEW York
Jackson Service Compa
NEW York to Pennsylvania
Certified Service Center Rons Service
CENTER, INC
Rhode Island to Wisconsin
Wisconsin to WYOMING/INTERNATIONAL
Jackson Technical Manual Addendum