Southbend STRE-5EZ, STRE-3EZ owner manual High-Limit Thermostats Check

Page 29

STRATOSTEAM COUNTERTOP STEAMER

SERVICE

Figure 17

High-Limit Thermostats Check

1.Allow cavity bottom to cool before performing this test.

2.DISCONNECT POWER AT CIRCUIT BREAKER.

3.Remove left side panel.

4.Disconnect wire B4 from left side of high-limit thermostat.

5.Disconnect wire B5 from right side of high-limit thermostat.

6.Disconnect remaining high-limit thermostat wires B11 and B12.

7.Test each high-limit thermostat for continuity (as shown above). There should be continuity when the thermostat is cool. Replace as necessary.

8.Reconnect wires.

OWNER’S MANUAL 1185184

PAGE 29 OF 44

Page 28 Page 30
Image 29
Page 28 Page 30
Contents
StratoSteam Safety Precautions Location of Serial Plates IntroductionClearances SpecificationsDimensions Dimensions Drain Requirements Electrical RequirementsWater Requirements Location of Water Trough OperationStartup OperationShutdown Troubleshooting by OperatorCooking Tips ControlsSuggested Cooking Times Daily Cleaning and Maintenance Cleaning & MaintenancePeriodic DE-LIMING AS Needed STAINLESS-STEEL SurfacesCleaning & Maintenance Stratosteam Countertop Steamer Unpacking InstallationAttach Legs and Brackets Attach Legs and BracketsMounting on Cabinet Base Stacking TWO SteamersElectrical Connection Location of Connections and VentsWater Connection Electrical Connection Check Steamer Operation Check the InstallationSHUT-DOWN and WIPE-CLEAN Steamer Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring Diagrams ServiceHOW the Steamer Operates How the Steamer Operates Disconnect Power AT Circuit Breaker Steamer Not Heating Up, Power Light Is Not LitCheck water-level control sensor see Replace water solenoid Buzzer Does Not Come On When Timer Runs Out Heating Cartridge Check at Contactor Disconnect Power AT Circuit BreakerPower Switch Check Contactor Check Timer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water-Level-Control Sensor Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt Models Wiring Diagram for 480 Volt Models Parts Parts Diagram3EZ 5EZ Structural PartsSee parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Heating Cartridges, Thermostats, and Contactor Parts Water Train Parts Water-Train PartsCabinet Base Parts Cabinet-Base Parts StratoSteam Countertop Steamer Models STRE-3EZ and STRE-5EZ