Craftsman 917.28922 owner manual Problemcause, Loss of power

Page 29

TROUBLESHOOTING CHART:

See appropriate section in manual unless directed to Sears service center

PROBLEMCAUSE

Engine clicks but 1 Weak or dead battery. will not start

2Corroded battery terminals.

3Loose or damaged wiring.

4Faulty solenoid or starter.

Loss of power

1 Cutting too much grass/too fast.

2Throttle in "CHOKE" position.

3Build-up of grass, leaves and trash under mower.

4Dirty air filter.

5Low oil level/dirty oil.

6Faulty spark plug.

7Dirty fuel filter.

8Stale or dirty fuel.

9Water in fuel.

CORRECTION

1Recharge or replace battery.

2Clean battery terminals.

3Check all wiring.

4Check/replace solenoid or starter.

1Raise cutting height/reduce speed.

2Adjust throttle control.

3Clean underside of mower housing.

4Clean/replace air filter.

5Check oil level/change oil.

6Clean and regap or change spark plug.

7Replace fuel filter.

8Empty fuel tank and refill tank witi- fresh, clean gasoline.

9Empty fuel tank and carburetor, refill tank with fresh gasoline and replace fuel filter.

10

Spark

plug

wire loose.

10

Connect

and

tighten

spark plug

wire.

11

Dirty

engine

air

screen/fins.

11

Clean

engine

air

screen/fins.

12

Dirty/clogged

muffler.

12

Clean/replace

muffler.

13

Loose

or damaged

wiring.

13

Check

all wiring.

14

Carburetor

out

of

adjustment.

14

See "To Adjust

Carburetor"

in

Service

and Adjustments

section.

15

Engine

valves

out

of

adjustment.

15

Contact

a Sears

or other

qualified

service

center.

Excessive

vibration

1

Worn,

bent

or loose

blade.

1

Replace

blade.

Tighten

blade bolt

2

Bent

blade

mandrel.

2

Contact

a Sears

or other

qualified

service

center.

3

Loose/damaged

part(s).

3

Tighten

loose

part(s).

Replace

damaged

parts.

Engine

continues

to

1

Faulty

operator-safety

presence

1

Check

wiring,

switches

and

run when

operator

control

system.

connections.

If not

corrected,

leaves

seat with

contact a Sears or other

attachment clutch

engaged

29

Image 29

Contents SEARS, Roebuckand CO., Hoffman ESTATES, IL 60179 U.S.A LAW TractoTWO Years on Riding Equipment Craftsman Full WarrantyGeneral Operation Safe Handling of Gasoline ServiceGeneral Service Repair Protection Product SpecificationsTo Adjust Seat Tools Required for AssemblyCheck Battery To Remove Tractor from CartonCheck Deck Levelness Check Tire PressureCheck for Proper Position of ALL Belts Check Brake System@@@ Reverse Operation System Know Your TractorStopping HOW to USE Your TractorTo SET Parking Brake To Adjust Gauge Wheels To Adjust Mower Cutting HeightTo Move Forward Backward To Operate MowerReverse Operation System ROS To TransportTransmission Engaged Transmission Disengaged To Start Engine Before Starting the EngineAutomatic Transmission Warm UP Check Engine OIL LevelMowing TiPS Purge TransmissionMaintenance Lubrication ChartGeneral Recommendations Before Each USEBrake Operation TractorTires Operator Presence System and Reverse Operation System ROSEngine Transaxle Pump FluidEngine Cooling System AIR FilterMuffler Spark PlugsDeck Washout Port Important Tug hose ensuring connec- tion is secureTo Remove Mower To Install Mower03042tex FRONT-TO-BACK Adjustment Visual SIDE-TO-SIDE AdjustmentPrecision SIDE-TO-SIDE Adjustment To Level MowerTo Replace Mower Blade Drive Belt Belt InstallationBelt Removal To Replace Motion Drive BeltTo Remove Wheel for Repairs To Adjust Choke Control To Remove Hood & Grill AssemblyTo Replace Headlight Bulb Interlocks and RelaysCylinders Fuel SystemEngine OIL Correction Problem CauseLoss of power ProblemcauseLevel mower deck ProblemOFF LossOnly Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationEspecifJcaciones del Producto Funcionamiento General Lesiones graves o la muerteIV. Remolque III. NiiosManipulacion Segura DE LA Gasolina Operaciones DE Servicio GeneralesPage Responsabilidades DEL Cliente Especificaciones DEL ProductoAcuerdos DE Proteccion Para LA ReparacionPara Remover EL Tractor DE Herramientas Necesarias Para EL MontajeLA Caja DE Carton Desempaque LA Caja DE Carton Verifique LA BateriaRevjsion DE LA Nivelacion DEL Conjunto Revision DE LA Presion DE LAS LlantasRevision DEL Sistema DE Frenos Jlista DE Revision@@@ Istema DE Funcionamiento Hacia Familiaricese CON SU TractorSU Tractor Parada Como Usar SU TractorMiento LA Segadora Para Operar EN Cerros Usar EL Sistema DE Funcionamiento ATR,SPara Transportar Transmision Enganchada Transmision DesenganchadaAgreguegasolina Consejos Para Segar Purgar LA TransmisionAntes DE Cada USO Tabla DE LubricacionRecomendaciones Generales Llantas TractorVI= Rifiez Sistema Func Ionam Iento AT R/,S ROS Cuidado DE LA CuchillaTranseje MotorCorreas Para Cambiar EL Aceite DEL MotorLimpieza Manguera Puerto de Lavado Adaptador de Boq Instale LA Segadora DE CespedPara Desmontar LA Cortadora 03042tex Regulacion Visual DE Lado a Lado Para Nivelar LA SegadoraRegulacion DE LA Precision DE Lado Ajuste DE Delante a ATR,SRemocion DE LA Correa Paracambiarla Correa DE Impulsion DE LA Cuchilla SegadoraInstalacion DE LA Correa Montaje DE LA CorreaPara ADJ Untar LOS CAB LES D E EM Palm E MEC.&NICOPara Cambiar EL Fusible Reemplazar LA BateriaPara Remover EL Conjunto DEL Capo Y DEL Enrejado Para Cambiar LA Bombilla DE LA LUZ DelanteraSistema DE Combustible OtrosAceite DEL Motor CilindrosEstrangulacion Choke Problema Causa CorreccionIDENTIFICACI6N DE Problemas Correccion Identificacion DE ProblemasProblemacausa Las cuchillas Page 15GRADOS MAX Operacion SeguraCuesta Abajo Y no Atraviese EL Cerro Needmorehelp