Stow manual Stow G-2.9R Safety Message Alert Symbols, Burn Hazards, Respiratory Hazards

Page 8

STOW G-2.9R — SAFETY MESSAGE ALERT SYMBOLS

FORYOUR SAFETY AND THE SAFETY OF OTHERS!

HAZARD SYMBOLS

Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others.

This Owner's Manual has been developed to provide complete instructions for the safe and efficient

NOTE operation of the STOW Model G-2.9R Portable Generator. Refer to the engine manufacturers instructions for data relative to its safe operation.

Before using this generator, ensure that the operating individual has read and understands all instructions in this manual.

SAFETY MESSAGE ALERT SYMBOLS

The three (3) Safety Messages shown below will inform you about potential hazards that could injure you or others. The Safety Messages specifically address the level of exposure to the operator, and are preceded by one of three words: DANGER,

DANGER

You WILL be KILLED or SERIOUSLY INJURED

if you DO NOT follow these directions.

WARNING

You CAN be KILLED or SERIOUSLY INJURED if

you DO NOT follow these directions.

CAUTION

You CAN be INJURED if you DO NOT follow these directions.

Potential hazards associated with the operation of a STOW G-2.9R Portable Generator will be referenced with Hazard Symbols which appear throughout this manual, and will be referenced in conjunction with Safety Message Alert Symbols.

WARNING Lethal Exhaust Gas Hazards

Engine exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. NEVER operate this equipment in a confined area or enclosed structure that does not provide ample free flow air.

WARNING Explosive Fuel Hazards

Gasoline is extremely flammable, and its vapors can cause an explosion if ignited. DO NOT start the engine near spilled fuel or combustible fluids.

DO NOT fill the fuel tank while the engine is running or hot. DO NOT overfill tank, since spilled fuel could ignite if it comes into contact with hot engine parts or sparks from the ignition system. Store fuel in approved containers, in well-ventilated areas and away from sparks and flames.

 

WARNING

Burn Hazards

Engine components can generate extreme heat. To prevent burns, DO NOT touch these areas while the engine is running or immediately after operations. Never operate the engine with heat shields or heat guards removed.

 

WARNING

Respiratory Hazards

ALWAYS wear approved respiratory protection when required.

PAGE 8 — STOW G-2.9R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #1 (10/28/04)

Page 7 Page 9
Image 8
Page 7 Page 9
Contents Model G-2.9R Page Heres HOW to GET Help Table of Contents Parts Ordering Procedures When ordering parts Please supply the following informationStow G-2.9R Dimensions DimensionsSpecifications Effects of Altitude and HeatRespiratory Hazards Stow G-2.9R Safety Message Alert SymbolsBurn Hazards Equipment Damage Rotating Parts HazardsStow G-2.9R Rules for Safe Operation Read this manualStow G-2.9R Rules for Safe Operation Stow G-2.9R Rules for Safe Operation EmergenciesPage Operation and Safety Decals S/N 5497956 and below Machine Safety DecalsOperation and Safety Decals S/N 5497957 and Above Stow G-2.9R General Information Stow G-2.9R FamilarizationControl Panel Excitation SystemExtension Cables Single Phase LoadStow G-2.9R Load Application Stow G-2.9R Controls and Indicators Generator Controls and ComponentsStow G-2.9R Controls and Indicators Stow G-2.9R Generator Refueling Generator RefuelingStow G-2.9R Installation Outdoor InstallationIndoor Installation MountingStow G-2.9R Installation Connecting the GroundGeneral Inspection Prior to Operation Ground Power Tools Stow G-2.9R PRE-INSPECTIONExtension Cable Main Circuit BreakerStow G-2.9R PRE-INSPECTION Engine Before StartingEngine Oil Check Fuel CheckStow G-2.9R Initial START-UP Engine Before Starting the EngineStopping The Engine Connecting the LoadStow G-2.9R Initial START-UP ENGINE/OPERATION Stow G-2.9R Preparation for Long -TERM Storage Generator StorageStow G-2.9R Maintenance Engine Engine Maintenance ScheduleMaintenance Stow G-2.9R Maintenance EngineCleaning the Fuel Strainer Stow G-2.9R Wiring Diagram S/N 5497956 and below Generator/Engine Wiring Diagram S/N 5497956 and BelowStow G-2.9R Wiring Diagram S/N 5497957 and Above Stow G-2.9R -TROUBLESHOOTING Engine Engine TroubleshootingStow G-2.9R -TROUBLESHOOTING Engine Stow G-2.9R -TROUBLESHOOTING Generator Generator TroubleshootingPage Items Found In the Items Number Column How to read the marks and remarks used in this parts bookStow G-2.9R Explanation of Code in Remarks Column Stow G-2.9R Suggested Spare Parts To 3 UnitsStow G-2.9R Name Plate and Decals S/N 5497956 and below Stow G-2.9R Name Plate and Decals S/N 5497956 and below Stow G-2.9R Name Plate and Decals S/N 5497957 and Above Part Name QTY Remarks Stow G-2.9R Generator Assy SET BOLT, Rotor Stow G-2.9R Control BOX ASSY. S/N 5497956 and below Stow G-2.9R Control BOX ASSY. S/N 5497956 and below Stow G-2.9R Control BOX ASSY. S/N 5497957 and Above Stow G-2.9R Control BOX ASSY. S/N 5497957 and Above Stow G-2.9R Pipe Frame ASSY. S/N 5497956 and below Stow G-2.9R Pipe Frame ASSY. S/N 5497956 and below Fuel GAUGE, CJ- 58AStow G-2.9R Pipe Frame ASSY. S/N 5497956 and Above A2417000302 Robin EX170D20210 Crankcase Assy Robin EX170D20210- Crankcase Assy Robin EX170D20210 Crankshaft and Piston Assy Crankshaft Assy Robin EX170D20210 Governor Assy Part Name QTY. Remarks Robin EX170D20210 Intake and Exhaust Assy PIN, CAM Shaft Robin EX170D20210 AIR Cleaner Assy Robin EX170D20210 AIR Cleaner Assy Robin EX170D20210 Cooling Starting Assy Blower Housing CP, Yellow Robin EX170D20210 -CARBURETOR Assy Robin EX170D20210 Carburetor Assy Robin EX170D20210 Flywheel Assy Part Name QTY Robin EX170D20210 Electric Device Assy OIL Sensor CP Terms and Conditions of Sale Stow Construction Equipment Terms and Conditions of Sale PartsPage Your Local Dealer is
Top Page Image Contents