Multiquip operation manual DCA-600SSK Generator START-UP Procedure Auto Mode

Page 49

DCA-600SSK — GENERATOR START-UP PROCEDURE (AUTO MODE)

DANGER - ELECTRICAL SYSTEM HAZARDS

Before connecting this generator to any building’s electrical system, a licensed electrician must install an isolation (transfer) switch. Serious damage to the building’s electrical system may occur without this transfer switch.

CAUTION - ENGINE SPEED SWITCH

The Engine Speed Switch must be set to the "High" position when running in the Auto-Startmode. Failing to set the switch in the proper position can result in damage to your generator when it turns on.

CAUTION - BACKUP GENERATOR USE

When connecting the generator to a isolation (transfer) switch, ALWAYS have power applied to the generator's internal battery charger. This will ensure that the engine will not fail due to a dead battery.

WARNING - AUTO MODE MAINTENANCE

When running the generator in the AUTO mode, remember the generator can start up at any time without warning. NEVER attempt to perform any maintenance when the generator is in the auto mode.

When starting generator in AUTO mode use the "Manual Start-up" procedure except where noted (see below).

1.Perform steps 1 through 4 in the Before Starting section (page 45) as outlined in the Manual Starting Procedure.

2.Set the battery ON/OFF switch (Figure 66) to the “ON” position.

When the generator is set in the “ AUTO ” mode, the generator will automatically start in the event of

NOTE commercial power falling below a prescribed level by means of a contact closure that is generated automatically by a transfer switch.

3.Set the engine speed switch (Figure 67) to the “High” position.

Figure 67. Engine Speed Switch (High)

4.Place the Off/Manual/Auto switch (Figure 68) on the MPEC unit to the AUTO position.

Figure 68. Off/Manual Auto Switch (AUTO)

5.Continue operating the generator as outlined in steps 11 thru 19 (pages 46-47).

Figure 66. Battery ON/OFF Switch

DCA-600SSK — OPERATION AND PARTS MANUAL (STD)— REV. #7 (04/30/10) — PAGE 49

Image 49
Contents Model DCA-600SSK Diesel engine exhaust and some Proposition 65WARNINGDCA-600SSK Operation and Parts Manual STD- REV. #7 04/30/10 Table of Contents Ordering parts has never been easier Parts Ordering ProceduresDCA-600SSK Specifications DCA-600SSK Operation and Parts Manual STD- REV. #7 04/30/10 Dimensions DCA-600SSK Dimensions TOP and SideDCA-600SSK Dimensions Front , Rear and Doors Hazard Symbols DCA-600SSK Safety Message Alert SymbolsThis generator, other property DCA-600SSK Safety Message Alert SymbolsBurns General SafetyDCA-600SSK Rules for Safe Operation Electrical SafetyGenerator Grounding Battery Safety Maintenance SafetyDCA-600SSK Rules for Safe Operation Towing & Transporting SafetyEmergencies Typical Generator Grounding Application DCA-600SSK InstallationOutdoor Installation DCA-600SSK InstallationMounting DCA-600SSK -TOWING Rules for Safe Operation Towing Safety PrecautionsExplanation of Chart DCA-600SSK TRAILER-SAFETY GuidelinesCoupler Type of hitch used on the trailer for towing DCA-600SSK -TRAILER-SPECIFICATIONS Specifications DCA-600SSK -TRAILER-SPECIFICATIONSMachine Safety Decals DCA-600SSK Operation and Safety DecalsDCA-600SSK Operation and Safety Decals DCA-600SSK Operation and Safety Decals DCA-600SSK Operation and Safety Decals DCA-600SSK General Information Generator Major Components DCA-600SSK Major ComponentsGenerator Control Panel DCA-600SSK Generator Control PanelPilot Lamp Indicates that the generator is working properly DCA-600SSK Generator Control PanelEngine Operating Panels DCA-600SSK Engine Operating PanelFuel Level Gauge Indicates amount of diesel fuel remaining Output Terminal Panel Output Terminal FamiliarizationDCA-600SSK Output Terminal Panel Overview Access to Uvwo Terminals120VAC Gfci Receptacles Maximum Power Output KW Connecting LoadsDCA-600SSK Output Terminal Panel Overview Over Current RelayThree Phase Load Single Phase LoadDCA-600SSK- Load Application Voltage Change-Over Board Generator OutputVoltagesGenerator Amperage 240V 480VDCA-600SSK Generator OUTPUTS/GAUGE Reading How to Read the Output Terminal GaugeMaximum Amps Uvwo Terminal Output Voltages DCA-600SSK Output Terminal Panel Connections3Ø-240V Uvwo Terminal Output Voltages 1Ø-240V Uvwo Terminal Output Voltages3Ø-480V Uvwo Terminal Output Voltages DCA-600SSK Output Terminal Panel Connections1Ø-480V Uvwo Terminal Output Voltages 1Ø-277V Uvwo Terminal Output VoltagesCircuit Breakers DCA-600SSK PRE-SETUPLubrication Oil Refueling Refueling ProcedureFuel from the secondary inner Full Trailer Tank Cleaning the Radiator DCA-600SSK- PRE-SETUPAir Cleaner Fan Belt Tension Operation Freezing WeatherBattery Cable Installation BatteryWiring AlternatorEngines exhaust contains harmful emissions DCA-600SSK GEN. START-UP Procedure ManualIf applicable perform the following Generator and Control PanelSet the battery ON/OFF switch to the on position DCA-600SSK- Generator START-UP Procedure ManualOil Pressure Gauge DCA-600SSK- Generator START-UP Procedure ManualPre-Heat Button Lamp DCA-600SSK Generator START-UP Procedure ManualSet the engine speed switch to the High position DCA-600SSK Generator START-UP Procedure Auto ModeEmergency Shutdown Procedure DCA-600SSK Generator SHUT-DOWN ProcedureEngine Shutdown Controller S/N 3698617~ Inspection / Maintenance DCA-600SSK MaintenanceService Daily Air CleanerCleaning the Fuel Strainer General InspectionChanging Oil Flushing Out Radiator and Changing CoolantReplacing Fuel Filter Greasing Cleaning Breather ElementGenerator Storage Removal From Long Term StorageBattery Charger/Jacket Water Heater Power Connections DCA-600SSK -TRAILER Brakes Maintenance Tires/Wheels/Lug Nuts DCA-600SSK -TRAILER MaintenanceTire Wear/Inflation SuspensionLug Nut Torque Requirements DCA-600SSK -TRAILER MaintenanceStart all wheel lug nuts by hand Lug nutsTrailer Wiring Diagram 5-Pin DCA-600SSK -TRAILER-WIRING DiagramDCA-600SSK -TRAILER-WIRING Diagram Generator Wiring Diagram DCA-600SSK -GENERATORWIRING DiagramMain Circuit Breaker Wiring Diagram DCA-600SSK Generator Wiring Diagram Main BreakerEngine Wiring Diagram DCA-600SSK Engine Wiring DiagramDCA-600SSK Engine Wiring Diagram Electronic Governor Controller DCA-600SSK Electronic GOV. Controller Wiring DiagramStarter does not run Engine does not startEngine revolution is not DCA-600SSK -TROUBLESHOOTING EngineSmooth Deficient outputGenerator Troubleshooting DCA-600SSK -TROUBLESHOOTING GENERATOR/ENGINEEngine Controller Troubleshooting Mpec DCA-600SSK -TROUBLESHOOTING MpecXxxxx only Not Used on Explanation of Code in Remarks ColumnDCA-600SSK w/SA6D170AE-1 Komatsu Engine DCA-600SSK Suggested Spare PartsQty Description Generator Assy DCA-600SSK Generator AssyField Assy Balancing Weight KITInsulator Washer FANDCA-600SSK Generator Assy Plain Washer GrommetCOVER, Bearing GASKET, BearingControl BOX Assy DCA-600SSK Control BOX AssyBracket Over Current RelayFuse Left Side 5A Fuse 30ADCA-600SSK Control BOX Assy Terminal Plate Change TerminalChange Plate WASHER, LockDCA-600SSK Control BOX Assy DCA-600SSK Control BOX ASSY. S/N 3692433 and below DCA-600SSK Control BOX Assy Speed Sensor Engine & Radiator Assy DCA-600SSK Engine & Radiator AssyBRACKET, Radiator Include Item WEngine Foot DCA-600SSK Engine & Radiator Assy AIR Cleaner Connector AIR Cleaner AssyGASKET, AC Connector BushingEngine Operating Panel Assy DCA-600SSK Engine Operating Panel AssySTAY, Battery Switch SET PLATE, Battery SwitchSupport LEG Rubber CoverOutput Terminal Assy DCA-600SSK Outputterminal AssyBRACKET, Output Terminal Output TerminalTerminal COVER, Output TerminalDCA-600SSK Outputterminal Assy Cover StopperBattery Assy DCA-600SSK Battery AssyBattery Sheet BatteryBattery Band Battery BoltMuffler Assy DCA-600SSK Muffler AssyExhaust Pipe MufflerOutlet Pipe GasketFuel Tank Assy DCA-600SSK Fueltank AssyTank Band HOSE, Fuel GaugePAD, Tank Band Tank SheetEnclosure #1 Assy DCA-600SSK Enclosure #1 AssyPart Name QTY Remarks Enclosure #2 Assy DCA-600SSK Enclosure #2 AssyLouver Panel Rear FrameCOVER, Rear Frame LiningDCA-600SSK Enclosure #2 Assy Emblem CAPRoof Panel GuideEnclosure #3 Assy DCA-600SSK Enclosure #3 AssySide Door Side PanelDuct HingeRubber Seal Assy DCA-600SSK Rubber Seal Assy0228900970 02289016400228901100 0228900990Name Plate and Decals DCA-600SSK Nameplate and DecalsZ011000130 Decal DROOP, Z011000120Z011000150 0800520100DCA-600SSK Nameplate and Decals Decal Handling Procedures Procedure GroupDecal 3-PHASE Output Terminal Decal Water Drain CockFreightpolicy Terms and Conditions of Sale PartsDCA-600SSK Operation and Parts Manual STD- REV. #7 04/30/10 HERE’S HOW to GET Help

DCA-600SSK specifications

The Multiquip DCA-600SSK is a rugged, reliable, and high-performance mobile generator that caters to a wide range of applications, from construction sites to outdoor events. Designed for durability and efficiency, the DCA-600SSK is notable for its robust construction and advanced technologies that ensure reliable power delivery.

At its core, the DCA-600SSK is powered by a reliable, fuel-efficient diesel engine. This engine not only provides consistent power output but also offers extended run times, making it ideal for long-duration use in remote locations. The generator delivers a remarkable 600 kVA of power, allowing it to support heavy machinery or multiple smaller loads simultaneously.

One of the standout features of the DCA-600SSK is its impressive sound attenuation design. The generator is enclosed in a weather-resistant, sound-attenuated housing that significantly reduces noise levels, making it suitable for use in noise-sensitive environments, such as residential areas or events.

Additionally, the DCA-600SSK is equipped with a user-friendly digital control panel that provides comprehensive monitoring capabilities. This panel includes features such as voltage and frequency regulation, along with automatic start/stop functionality, which enhances both ease of use and operational efficiency. The digital display allows operators to monitor critical parameters at a glance, ensuring optimal performance and safety.

The generator is also designed with mobility in mind. It comes with forklift pockets and lifting hooks, making it easy to transport and relocate. This portability ensures quick setup and deployment, which is especially advantageous in dynamic job sites or temporary power needs.

Another important characteristic of the DCA-600SSK is its dual-frequency capability. It can operate at either 50 Hz or 60 Hz, making it versatile for international applications. This adaptability enables users to utilize the generator in various regions without modifying equipment or loads significantly.

Finally, safety features are paramount in the design of the DCA-600SSK. It includes fully automatic safety shutdowns for low oil pressure, high coolant temperature, and overload protection, safeguarding the generator from potential damage and ensuring dependable performance in demanding conditions.

In summary, the Multiquip DCA-600SSK is a powerhouse generator combining high performance, advanced technology, and user-centric design. Its efficiency, portability, and durability make it an excellent choice for professionals seeking reliable power solutions in various settings.