Exmark FMD604 manual Riding Attachments, Safety Signs

Page 12

1.5.7Gasoline powered equipment or fuel containers should not be stored in a basement or any enclosed area where open pilot lights or heat appliances are present.

1.5.8Maximum mowing results and safety can only be achieved if the mower is properly maintaine and operated correctly.

1.5.9Check all bolts frequently to maintain proper tightness.

1.5.10Keep all guards, shields, and all safety devices in place and in safe working condition.

1.5.11Frequently check for worn or deteriorating components that could create a hazard.

1.5.12All replacement parts must be the same as or equivalent to the parts supplied as

original equipment.

WARNING

POTENTIAL HAZARD

Hydraulic fluid escaping under pressure can penetrate skin and cause injury.

WHAT CAN HAPPEN

Fluid accidentally injected into the skin must be surgically removed within a few hours by a doctor familiar with this form of injury or gangrene may result.

HOW TO AVOID THE HAZARD

Make sure all hydraulic fluid hoses and lines are in good condition an all hydraulic connections and fittings are tight before applying pressure to hydraulic system.

Keep body and hands away from pinhole leaks or nozzles that eject high pressure hydraulic fluid.

Use cardboard or paper, not your hands, to find hydraulic leaks.

Safely relieve all pressure in the hydraulic system by locking drive levers in neutral and shutting off the engine before performing any work on the hydraulic system.

1.6RIDING ATTACHMENTS

Use only Exmark riding attachments. The use of other than Exmark riding attachments may create a hazardous condition resulting in injury.

1.7SAFETY SIGNS

1.7.1Keep all safety signs legible. Remove all grease, dirt, and debris from safety signs and instructional labels.

1.7.2Safety signs must be replaced if they are missing or illegible.

1.7.3When new components are installed, be sure that current safety signs are affixed to the replaced components.

1.7.4New safety signs may be obtained from your authorized Exmark equipment dealer or distributor or from Exmark Mfg. Co. Inc.

1.7.5Safety signs may be affixed by peeling off the backing to expose the adhesive surface. Apply only to a clean, dry surface. Smooth to remove any air bubbles.

1.7.6Familiarize yourself with the following safety signs and instruction labels. They are critical to the safe operation of your Exmark commercial mower.

- 7 -

Image 12
Contents For Turf Tracer Serial Nos ,000 & Higher FMD524 & FMD604 Potential Hazard Exmark Parts Plus Program Operators Manual Table of Contents Safety Safety Alert SymbolYour Safety is Involved TrainingCarbon monoxide can kill you Potential Hazard Operation Potential Hazard Maintenance and Storage Safety Signs Riding AttachmentsDecals for ECS Handle units only Page Specifications Dimensions Wheel Drive SystemTires Mower DeckAssembly Instructions Service BatteryUncrate Unit Mower Deck Installation Drive WheelsService Hydraulic OIL HEX Stationary Idler InstallationPosition Discharge Chute Support PIN LocationPerform Necessary Adjustments Operation InstructionsGrease Unit Familiarize Yourself with the ControlsPage PRE-START Operating InstructionsPotential Hazard Drive LEVER, Neutral Lock Latch Operation Rotating blades under the mower deck are dangerous Maintenance & Adjustments TransportingPeriodic Maintenance Service Interval Daily or more often in dry conditionsBlade Bolt Installation Page Service Interval After First 250 hrs, then yearly thereafter Charge Pump Location Lubrication Chart Locations Pumps Places IntervalService Interval Once Yearly Caster Wheel AssemblyPage Adjustments Cutting Height Adjustment Neutral Safety Switch Adjustment Hydro Drive Linkage Adjustment Hydro Control LINKAGE/SWIVEL AdjustmentMake this adjustment for both sides Hydro Pump Spring Tension Setting Throttle TensionTrouble Shooting Waste DisposalEngine Troubleshooting Engine Troubleshooting TableProblem Hydraulic Schematic Wiring Diagrams Limited Warranty Exmark Turf Equipment Service Record Fold Along Appropriate Line See EXMARK’S Complete Line of Products for Turf Care