Husqvarna 240440 owner manual Tufftorq Transaxle Model Number K46BT

Page 45

TRACTOR - - MODEL NUMBER YTH2348 (240440)

TUFFTORQ TRANSAXLE MODEL NUMBER K46BT

KEY	PART
NO.	NO.		DESCRIPTION
7	532	41 43-95	Vent Valve 15
8	532	41 43-96	Magnet
9	532	41 43-97	Magnet	Holder
10	532	41 59-23	Pump Shaft/Bearing Kit
13	532	41 43-98	Bypass	Lever
15	532	41 43-99	Sealing	Cap 30
16	532	41 44-00	Snap Ring C 35

19532 41 44-01 O-Ring la Pl0a

20532 41 44-02 Seal Tc 153507

33532 41 44-03 Pump Shaft (Standard)

34532 41 44-04 E-Ring 15

35532 41 44-05 Bearing 6202c3

53532 41 44-31 Control Lever F

55532 41 59-24 Washer 12

58532 41 59-25 Roll Pin 6 * 40

59532 41 59-26 O-Ring la P14

60532 41 59-27 Nut 12

72532 41 44-07 Seal 19"32"8

76532 41 44-08 Brake Lever

78532 41 44-09 Brake Return Spring

80532 41 44-10 Spring Pin 5" 32

81532 41 44-11 0-Ring 1aP12

82532 41 44-12 Spring Pin 4" 16

83532 41 44-13 Spine Collar

84532 41 44-14 Pulley L

85532 41 44-15 Fan, Black

86532 41 44-16 Wave Washer

87 532 41 44-17 Snap Ring

90532 41 44-18 Spring Pin 3.0a * 20

91532 41 44-19 Oil Seal 16" 22 *.03

95532 41 48-50 Spring Pin 3.0a'16

96532 41 44-20 Roll Pin 3.5 * 40

11553241 59-28 Switch 6440-11 Delta

116532 41 59-29 Switch Bracket

117532 41 59-30 Tapping Screw 8 * 20

NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm

45

Image 45

Contents 532 44 General Operation Safe Operation Practices for Ride=On MowersII. Slope Operation Defects or other reproductive harm. Wash handsRules ServiceSafe Operation Practices IV. TowingContents Steering Wheel Unassembled PartsTools Required for Assembly AssemblyTo Remove Tractor from Carton Before Removing Tractor from SkidCheck Tire Pressure To Adjust Seat See FigCheck Deck Levelness Check for Proper Position of BeltsSystem ROS OperationKnow Your Tractor To SET Parking Brake See Fig HOW to USE Your TractorStopping See Fig To USE Throttle Control D See FigTo Adjust Gauge Wheels See Fig To Adjust Mower Cutting HeightTo Move Forward and Backward To USE Cruise Control J See FigReverse Operation System ROS To Stop Mower BladesTo Operate on Hills To Transport See FigsBefore Starting the Engine Service REMINDER/HOUR MeterCheck Engine OiL Level ADD GasolinePurge Transmission Mowing TipsGeneral Recommendations MaintenanceSchedule Before Each USETractor BatteryBlade Care Blade Removal See Fig=BELTS Clean AIR ScreenTransaxle Cooling Transaxle Pump FluidMuffler CleaningIN=LINE Fuel Filter See Fig Deck Washout Port See FigTo Install Mower See Figs Service and AdjustmentsTo Remove Mower See Fig Tachment Lift Lever SeeAdjustments = Turn Steering Wheel Left and Position Mower See FigANTI=SWAY Attach Rear Lift Links C See Fig Attach Mower Side Suspension Arms a to Chassis See FigYour hands with gloves and/or wrap To Level MowerTo Replace Motion Drive Belt To Replace Mower Blade Drive BeltTo Check Brake To Adjust Steering Wheel AlignmentTo Remove Wheel See Fig Front Wheel TOE-IN/CAMBEREngine TransmissionSee Fig Other TractorFuel System Engine OiLTroubleshooting Poor cut = uneven Battery Will notWorking If so ChargeTractor - Model Number YTH2348 SchematicElectrical NO. NO.DESCRIPTION KEY PartTractor - Model Number YTH2348 Chassis KEY Chassis Tractor - Model NumberTractor - Model Number YTH2348 Drive Idler Flat DriveEngine DESCRiPTiON Tractor - Model Number YTH2348 EngineI68 Steering AssemblyDescription Seat AssemblyTractor - Model Number YTH2348 Mower Deck KEY Part Description Mower DeckMower Lift Wheels and Tires Tractor - Model Number YTH2348 DecalsNO. NO.DESCRiPTiON NO. NO.DESCRIPTIONTufftorq Transaxle Model Number K46BT Model K46BTTufftorq Transaxle Model Number K46BT 10t LO5@ Tractor - Model Number YTH2348I33 Kit Magneto Side 133 699724 Pump 524 691032 Seal-Dipstick Tube 1022 690971 Consumer Wheeled Products Limited Warranty HOW to Obtain Service 11111111111111111111 Consumer Wheeled Warranty ChartAll other Pressure Washers 6027PW, 9032PW, 1340PW Only Ride UP and Down HILL, not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationHusqvarna