Carrier 50PCH specifications

Contents

Main Installation, Start-Up, and Service Instructions CONTENTS SAFETY CONSIDERATIONS GENERAL INSTALLATION Step 1 Check Jobsite Step 2 Check Unit Page LEFT RETURN RIGHT RETURN Fig. 1 50PCH Unit Dimensions a50-8695 UNIT HANGER DETAIL 50PCH006-060 UNITS Fig. 2 Typical Installation 50PCH Units a50-7842ef UNIT HANGER ISOLATION DETAIL TOP VIEW-LEFT RETURN TOP VIEW-FRONT RETURN Fig. 3 50PCV Unit Dimensions a50-8696 Step 3 Locate Unit Step 4 Mount the Unit Step 5 Check Duct System Step 6 Install Condensate Drain Step 7 Pipe Connections Step 8 Wire Field Power Supply a50-8490 Fig. 13 50PCH,PCV Units with Complete C Controller, Single-Phase Complete C a50-8491 Fig. 14 50PCH,PCV Units with Deluxe D Controller, Three-Phase (208/230 V) Deluxe D a50-8492 Fig. 15 50PCH,PCV Units with Deluxe D Controller, Three-Phase (460 V) Deluxe D Fig. 16 50PCH,PCV Units with Complete C and LON Controller (460 V) a50-8493 1. Compressor and blower motor thermally protected internally. Fig. 17 50PCH,PCV units with Deluxe D and LON Controller (460 V) a50-8440 Deluxe D Page Page a50-8380 Fig. 20 WSHP Open Control WSHP Open Inputs and Outputs Table Table 3 50PCH,PCV Unit Electrical Data a50-8162 Fig. 21 Typical Single-Phase Line Voltage Power Connection Step 9 Wire Field Controls Page PRE-START-UP System Checkout PSC (Permanent Split Capacitor) Blower Speed Selection Table 9 50PCH,PCV Blower Performance Standard Unit Table 10 50PCH,PCV Blower Performance High-Static Unit FIELD SELECTABLE INPUTS Complete C Control Jumper Settings (Refer to Fig. 13 and 16) Complete C Control DIP Switches Deluxe D Control Jumper Settings (Refer to Fig. 14, 15, and 17) Deluxe D Control DIP Switches Deluxe D Control Accessory Relay Configura- tions Water Valve (Slow Opening) Outside Air Damper (OAD) START-UP Operating Limits Scroll Compressor Rotation Unit Start-Up Cooling Mode Table 15 50PC006 Typical Unit Operating Pressures and Temperatures Table 16 50PC009 Typical Unit Operating Pressures and Temperatures Table 17 50PC012 Typical Unit Operating Pressures and Temperatures Table 18 50PC015 Typical Unit Operating Pressures and Temperatures Table 19 50PC018 Typical Unit Operating Pressures and Temperatures Table 20 50PC024 Typical Unit Operating Pressures and Temperatures Table 21 50PC030 Typical Unit Operating Pressures and Temperatures Table 22 50PC036 Typical Unit Operating Pressures and Temperatures Table 23 50PC042 Typical Unit Operating Pressures and Temperatures Unit Start-Up Heating Mode Unit Start-Up with WSHP Open Controls Page Flow Regulation Flushing Antifreeze Cooling Tower/Boiler Systems OPERATION Power Up M ode Units with Aquazone Complete C Control Units with Aquazone Deluxe D Control Units with WSHP Open Multiple Protocol Page Page COMPLETE C AND DELUXE D BOARD SYSTEM TEST Test Mode WSHP Open Test Mode Retry Mode Aquazone Deluxe D Control LED Indica- tors SERVICE Filters Water Coil Condensate Drain Pans Refrigerant System Air Coil Cleaning Condenser Cleaning Checking System Charge Refrigerant Charging Air Coil Fan Motor Removal Replacing the WSHP Open Controllers Battery TROUBLESHOOTING (Fig. 32 and 33, and Table 32) Thermistor Control Sensors Table 32 Troubleshooting Table 32 Troubleshooting (cont) APPENDIX A WSHP OPEN SCREEN CONFIGURATION Page APPENDIX A WSHP OPEN SCREEN CONFIGURATION (cont) Page Page Page Page Page Page HEATING CYCLE ANALYSIS COOLING CYCLE ANALYSIS 97B0038N05 a50-8446 a50-8445