Programming

The wash cycle program in machines equipped with a mechanical timer can be modified to a limited extent. The following changes can be made:

●The prewash time may be set to 2 minutes, 4 minutes, or omitted altogether.

●The wash time may be set to either 4 minutes or 8 minutes. The water level for the wash step may be set to either low or high.

●The water temperature for the rinses may be set to either cold or warm.

●The final spin time may be set to either 2 minutes or 4 minutes.

WARNING

This machine must be installed, adjusted, and serviced by qualified electrical maintenance personnel familiar with the construction and operation of this type of machinery. They must also be familiar with the potential hazards involved. Failure to observe this warning may result in personal injury and/or equipment damage, and may void the warranty.

SW004

WARNING

Dangerous voltages are present in the electrical control box(es) and at the motor terminals. Only qualified personnel familiar with electrical test procedures, test equipment, and safety precautions should attempt adjustments and troubleshooting. Disconnect power from the machine before removing the control box cover, and before attempting any service procedures.

SW005

Setting the Jumpers

WARNING

Attempting jumper configurations other than those described in this manual may result in personal injury and/or equipment damage, and may void the warranty.

SW041

NOTE: The following procedures must be performed by a qualified electrician familiar with the construction and operation of this type of machinery.

1.Disconnect power to the machine.

2.Remove the screws securing the control module cover to the control module.

3.Lift the control module cover and slide cover towards the rear of the machine.

4.The mechanical timer is located in the control module. The odd-numbered side of the timer is used to change the duration of individual cycle steps. See Figure 4.

Eleven permissible jumper configurations are available for changing the cycle time. See the table below.

19b 19 19a

17b 17 17a

15b 15 15a

13b 13 13a

11b 11 11a

9b 9 9a

7b 7 7a

5b 5 5a

3b 3 3a

1b 1 1a

Figure 4

F232088

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

19