Manuals / Alto-Shaam / Kitchen Appliance / Double Oven

Alto-Shaam 1000-SK/II mid bonnet assembly - 1767-SK shown, cable heating kitS, DANgEr, s erv ice

Models: 1000-SK/II 1000-SK-I 1767-SK

1 30

Download 30 pages 63.69 Kb

Page 26

mid bonnet assembly - 1767-SK shown

s erv ice

mid bonnet assembly - 1767-SK shown

1	2	3

56

4

7

8

16

9

10

15

11

12

14

13

Part numbers and drawings are subject to change without notice..

ITEM	DESCRIPTION	PART No.	QTY	ITEM	DESCRIPTION	PART No.	QTY
1	MID-BONNET SPOT ASSB	5012422	1	9	NUT, HEX #8-32	NU-2296	2
2	CONTROL	CC-34488	1	10	Bracket, PILOT LIGHT MTG	1004360	1
3	NUT, M4-0..7 HEX 18-8	NU-2296	2	11	PILOT LIGHT, WHITE, 250V	LI-3951	1
4	WASHER, M4 SPLIT LOCK S/S 18-8	WS-22300	2	12	CONNECTOR-5 CONDUCTOR	CR-34646	2
5	CONNECTOR	CR-34559	2	13	SCREW, 8-32 x 1/2", PHIL	SC-2425	2
6	CABLE, WIRE HARNESS	CB-34945	1	14	KNOB, T-STAT CONTROL	KN-26568	3
7	THERMOSTAT,COOK	TT-34910	1	15	SWITCH, ROCKER, 125-277V,20A	SW-34769	1
8	TIMER, 1HR, 208/240V	TR-34539	1	16	OVERLAY, MID BONNET control	PE-29441	1

cable heating kitS

	cable heating kit >	#4878	#4881
	cable heating kit >	120V	208-240V
	(one kit required per cavity)	120V	208-240V
	(one kit required per cavity)		230V
			230V
item	DESCRIPTION	qty	qty
cb-3045	cable heating element	112 ft..	210 ft..
cr-3226	ring connector	6	12
in-3488	insulation corner	1 ft..	1 ft..
bu-3105	shoulder bushing	6	12
bu-3106	cup bushing	6	12
st-2439	stud	6	12
nu-2215	hex nut	12	24
sl-3063	insulating sleeve	6	12
ta-3540	electrical tape	1 roll	1 roll

DANgEr

LOcK-OUT Or POST BrEAKEr PANEL UNTIL SErVIcE wOrK hAS BEEN cOMPLETED.

DANgEr

DIScONNEcT UNIT frOM POwEr SOUrcE BEfOrE cLEANINg Or SErVIcINg.

simple control smokers • installation/operation/service manual - pg. 24

Image 26

Alto-Shaam 1000-SK/II, 1000-SK-I mid bonnet assembly - 1767-SK shown, cable heating kitS, DANgEr, s erv ice, Description

Contents

Operation InstallationMaintenance ModelsWire Diagrams InstallationService WarrantySee Transportation Damage and Claims section located in this manual D E L I V E r YU N P A c K I N g w A r N I N g SAfETY PrOcEDUrES AND PrEcAUTIONSD A N g E r c A U T I O Ni n s t a l l a t i o n SITE INSTALLATIONDANgEr D A N g E r1767-SK s i t e INSTALLATION767-SK volume maximum 53 quarts 67 literss i t e INSTALLATION 1000-SK-I1000-SK/II volume maximum 60 quarts 76 literss i t e INSTALLATION OPTIONS AND ACCESSORIESfactory installed options i n s t a l l a t i o ni n s t a l l a t i o n STAcKINg INSTrUcTIONSs i t e INSTALLATION rISK Of ELEcTrIc ShOcK LEVELINGRESTRAINT REQUIREMENTS -MOBILE EQUIPMENT s i t e INSTALLATIONi n s t a l l a t i o n drip tray installation instructionss i t e INSTALLATION b a d cDANgEr ENSURE POWER SOURCE MATCHES VOLTAGE STAMPED ON APPLIANCE NAMEPLATEE L ECTRICAL CONNECTION DANgErE L ECTRICAL CONNECTION Wire diagrams are located inside the bonnet of the uniti n s t a l l a t i o n ELECTRICAL - 767-SKO P ERA T I NG INSTRUCTIONS U S ER SAFETY INFORMATIONDIScONNEcT UNIT frOM POwEr SOUrcE BEfOrE cLEANINg Or SErVIcINg START - UP OPERATION60 to 205F 16 to 96C Heatthe ºC or ºF setting selected by the user when power is restoredO P ERA T I NG INSTRUCTIONS 200 to 325F 94 to 160CMEAT O P ERA T I NG INSTRUCTIONSGeneral Holding Guideline fAhrENhEITCARE and cleaning cLEANINg AND PrEVENTIVE MAINTENANcEDANgEr care and cleaningENSURE POWER SOURCE MATCHES VOLTAGE STAMPED ON APPLIANCE NAMEPLATE D A N g E rNUTRITION FOOD AND DRUG ADMINISTRATION 1-888-SAFEFOOD Sa n i t a t i o nCENTER FOR FOOD SAFETY AND APPLIED To test probe and air sensor TROUBLE SHOOTING CHECKLISTServ ice Oven will cook in time onlys erv ice LOcK-OUT Or POST BrEAKEr PANEL UNTIL SErVIcE wOrK hAS BEEN cOMPLETEDSERVICE VIEW - single compartment 1000-SK/II Shown A DIScONNEcT UNIT frOM POwEr SOUrcE BEfOrE cLEANINg Or SErVIcINg767-SK SERVICE PARTS LIST - single compartmentmodel 1000-SK/IIDIScONNEcT UNIT frOM POwEr SOUrcE BEfOrE cLEANINg Or SErVIcINg EXTERIOR VIEW - double compartment 1000-SK-I ShownLOcK-OUT Or POST BrEAKEr PANEL UNTIL SErVIcE wOrK hAS BEEN cOMPLETED DANgEr1767 EXTERIOR PARTS LIST - double compartmentmodel 1000-SK-IDIScONNEcT UNIT frOM POwEr SOUrcE BEfOrE cLEANINg Or SErVIcINg electronic components - 767-SK, 120V shownLOcK-OUT Or POST BrEAKEr PANEL UNTIL SErVIcE wOrK hAS BEEN cOMPLETED DANgErLOcK-OUT Or POST BrEAKEr PANEL UNTIL SErVIcE wOrK hAS BEEN cOMPLETED mid bonnet assembly - 1767-SK showncable heating kitS DIScONNEcT UNIT frOM POwEr SOUrcE BEfOrE cLEANINg Or SErVIcINgPage  simple control smokers Page Voltage Purchased From LIMITED WARRANTYTRANSPORTATION DAMAGE and CLAIMS