
6
Trouble
Shooting
For repairs beyond the minor adjustments listed here, contact an authorized service dealer.
Problem |
| Cause |
| Remedy |
|
|
|
|
|
Engine fails to start | 1. | Throttle lever not in correct starting | 1. | Move throttle lever to FAST or |
|
| position (if equipped). |
| START position. |
| 2. | Spark plug wire disconnected. | 2. | Connect wire to spark plug. |
| 3. | Choke not in CHOKE position (if | 3. | Move choke lever to CHOKE |
|
| equipped). |
| position. |
| 4. | Fuel tank empty or stale fuel. | 4. | Fill tank with clean, fresh gasoline. |
| 5. | Engine not primed (if equipped). | 5. | Prime engine as instructed in |
|
|
|
| Engine Manual. |
| 6. | Faulty spark plug. | 6. | Clean, adjust gap, or replace. |
|
|
| ||
| 7. | Blocked fuel line. | 7. | Clean fuel line. |
|
|
| ||
| 8. | Engine flooded. | 8. | Wait a few minutes to restart, but |
|
| do not prime. | ||
|
|
|
| |
Engine runs erratic | 1. | Spark plug wire loose. | 1. | Connect and tighten spark |
|
|
|
| plug wire. |
| 2. | Unit running on CHOKE (if equipped). | 2. | Move choke lever to OFF position. |
| 3. | Blocked fuel line or stale fuel. | 3. | Clean fuel line; fill tank with clean, |
|
|
|
| fresh gasoline. |
| 4. | Vent in gas cap plugged. | 4. | Clear vent. |
| 5. | Water or dirt in fuel system. | 5. | Drain fuel tank. Refill with |
|
|
|
| fresh fuel. |
| 6. | Dirty air cleaner. | 6. | Refer to engine manual. |
| 7. | Carburetor out of adjustment. | 7. | See authorized service dealer. |
|
|
|
|
|
Engine overheats | 1. | Engine oil level low. | 1. | Fill crankcase with proper oil. |
| 2. | Dirty air cleaner. | 2. | Refer to engine manual. |
| 3. | Carburetor not adjusted properly. | 3. | See authorized service dealer. |
Occasional skips | 1. | Spark plug gap too close. | 1. | Adjust gap to .030”. |
(hesitates) at | 2. | Carburetor idle mixture adjustment | 2. | See authorized service dealer. |
high speed |
| improperly set. |
|
|
|
|
|
|
|
Excessive | 1. | Loose parts or damaged impeller. | 1. | See authorized service dealer. |
Vibration |
|
|
|
|
|
|
|
|
|
Unit does not | 1. | Chute deflector clogged. | 1. | Stop engine immediately and |
discharge |
|
|
| disconnect spark plug wire. Clean |
|
|
| flail screen and inside of discharge | |
|
|
|
| |
|
|
|
| opening. |
| 2. | Foreign object lodged in impeller. | 2. | Stop engine and disconnect spark |
|
|
| ||
|
|
|
| plug wire. Remove lodged object. |
| 3. | Low engine RPM. | 3. | Always run engine at full throttle. |
|
|
|
|
|
Rate of discharge | 1. | Low engine RPM. | 1. | Always run engine at full throttle. |
slows considerably | 2. | Chipper blade dull. | 2. | Replace chipper blade or see your |
or composition of |
|
|
| authorized service dealer. |
discharged material |
|
|
|
|
changes |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
14