Manuals / Exmark / Household Appliance / Vacuum Cleaner

Exmark 920, 000 & higher manual Electrical Schematic, Schematics

Models: 920 000 & higher

1 60

Download 60 pages 42.39 Kb

Page 53

Electrical Schematic

Schematics

Electrical Schematic

53

Image 53

Exmark 920, 000 & higher manual Electrical Schematic, Schematics

Contents

Part No. 4500-919Rev. A LAZER Z D-SERIESFor Serial Nos 920,000 & Higher Lazer Z LZD Units CALIFORNIA Proposition 65 Warning Model No Serial No IntroductionContents Safety Alert Symbol SafetySafety Safe Operating PracticesSafety DANGEROperation DANGER Slope OperationSafety Maintenance and Storage Using the Rollover Protection System ROPSSafety Do Not wear seat belt when the roll bar is downAlways shield eyes and face from battery SafetyDANGER DANGERHydraulic fluid escaping under pressure can penetrate skin and cause injury. Fluid accidentally injected into the skin must be surgically removed within a few hours by a doctor familiar with this form of injury or gangrene may result SafetySafety Safety and Instructional Decals103-2076 Safety103-0223 103-0261 109-1399 Safety109-0872 109-2264 109-2478 Safety116-0127 116-0404 Safety116-3303 117-271819426-87881 Safety107-9866 FastSpecifications SpecificationsSafety Interlock System Model NumbersHydrostatic Ground Drive System SeatTires & Wheels Cutting DeckCurb Weight DimensionsTorque Requirements Overall WidthOperation Product OverviewControls OperationTracking Adjustment Knob Ignition SwitchBrake Lever Hour MeterCoolant Temperature Gauge PTO Engagement SwitchGlow Plug Switch and Light Pre-StartBiodiesel Ready Operating InstructionsRaise the Rollover Protection System ROPS Open the Fuel Shut-OffValveDisengaging the PTO Engaging the PTOStopping the Engine OperationDriving the Machine Adjusting the Cutting HeightUse caution when making turns OperationOperation Adjusting the Anti-ScalpRollersTransporting a Unit TransportingLoading a Unit OperationMaintenance MaintenanceRecommended Maintenance Schedules Check Battery Charge Periodic MaintenanceService Interval Before each use or daily Service Interval MonthlyService Interval As required Recommended Jump Starting ProcedureMaintenance DANGERService Interval Before each use or daily Check Mower BladesMaintenance Check Rollover Protections Systems Roll Bar Pins Check Safety Interlock SystemService Air Cleaner Check Seat BeltService Interval Every 40 hours Service Interval After the first 5 hoursChange Engine Oil Check Hydraulic Oil LevelLubricate Grease Fittings Check Condition Of BeltsMaintenance Service Interval: Every 40 hoursService Interval Every 160 hours Wheel Hub - Slotted Nut Torque SpecificationLubricate Caster Wheel Hubs Lubricate Brake Handle PivotEvery 250 hours/Yearly if using Mobil 1 15W50 Service Interval After the first 250 hoursLubricate Motion Control Bronze Bushings Drain Fuel Filter/Water SeparatorChange Engine Coolant Check Engine Coolant LevelMaintenance Service Interval Before each use or dailyCheck Spark Arrester if equipped Service Interval Every 50 hoursThread Locking Adhesives MaintenanceMobil HTS Grease Or Food-Grade Anti-seize AdjustmentsCopper-Based Anti-seize Dielectric GreasePump Drive Belt Tension Mule Drive Belt Tension AdjustmentDeck Belt Tension MaintenanceParking Brake Adjustment Belt Guide AdjustmentService Interval After the first 100 hours Alternator Belt Tension5.Remove the rear tires from the machine MaintenanceRemoving the Shim Electric Clutch AdjustmentMaintenance Maintenance Reverse Indicator AdjustmentMotion Control Linkage Adjustment because of the jumper wire being used. Run MaintenanceMaintenance Motion Control Damper AdjustmentCaster Pivot Bearings Pre-LoadAdjustment Clean Engine Cooling System CleaningClean Engine and Exhaust System Area Clean the RadiatorClean Grass Build-UpUnder Deck Clean Debris From MachineBattery Disposal Waste DisposalTroubleshooting TroubleshootingProblem TroubleshootingPossible Cause Corrective ActionProblem TroubleshootingPossible Cause Corrective ActionElectrical Diagram SchematicsSchematics Schematics Electrical Schematic2 Year Limited Warranty Exmark Commercial Turf EquipmentInstructions for Obtaining Warranty Service Owner’s ResponsibilitiesPage Page Service Done By Service RecordDate Description of Work DonePage This page may be copied for personal use WALK-BEHINDACCESSORIES AND OPTIONS MID-MOUNTRIDING ACCESSORIES AND OPTIONSOUT-FRONTRIDING ACCESSORIES AND OPTIONS