Manuals
/
Exmark
/
Household Appliance
/
Vacuum Cleaner
Exmark
920, 000 & higher manual
Models:
920
000 & higher
1
55
60
60
Download
60 pages
42.39 Kb
52
53
54
55
56
57
58
59
<
>
Troubleshooting
Specs
Schematics
Warranty
Dimension
Maintenance
Problem
Tracking Adjustment Knob
Check Battery Charge
Cleaning
Page 55
Image 55
Notes:
55
Page 54
Page 56
Page 55
Image 55
Page 54
Page 56
Contents
For Serial Nos 920,000 & Higher Lazer Z LZD Units
LAZER Z D-SERIES
Part No. 4500-919Rev. A
CALIFORNIA Proposition 65 Warning
Model No Serial No
Introduction
Contents
Safe Operating Practices
Safety
Safety Alert Symbol
Safety
Operation
DANGER
Safety
Safety
Slope Operation
DANGER
Do Not wear seat belt when the roll bar is down
Using the Rollover Protection System ROPS
Maintenance and Storage
Safety
DANGER
Safety
Always shield eyes and face from battery
DANGER
Hydraulic fluid escaping under pressure can penetrate skin and cause injury. Fluid accidentally injected into the skin must be surgically removed within a few hours by a doctor familiar with this form of injury or gangrene may result
Safety
Safety
Safety and Instructional Decals
103-0223 103-0261
Safety
103-2076
109-0872
Safety
109-1399
109-2264 109-2478
Safety
117-2718
Safety
116-0127 116-0404
116-3303
Fast
Safety
19426-87881
107-9866
Model Numbers
Specifications
Specifications
Safety Interlock System
Cutting Deck
Seat
Hydrostatic Ground Drive System
Tires & Wheels
Overall Width
Dimensions
Curb Weight
Torque Requirements
Operation
Product Overview
Operation
Controls
Hour Meter
Ignition Switch
Tracking Adjustment Knob
Brake Lever
Warning Buzzer
PTO Engagement Switch
Glow Plug Switch and Light
Pre-Start
Open the Fuel Shut-OffValve
Operating Instructions
Biodiesel Ready
Raise the Rollover Protection System ROPS
Operation
Engaging the PTO
Disengaging the PTO
Stopping the Engine
Operation
Adjusting the Cutting Height
Driving the Machine
Use caution when making turns
Operation
Adjusting the Anti-ScalpRollers
Operation
Transporting
Transporting a Unit
Loading a Unit
Recommended Maintenance Schedules
Maintenance
Maintenance
Service Interval Monthly
Periodic Maintenance
Check Battery Charge
Service Interval Before each use or daily
DANGER
Recommended Jump Starting Procedure
Service Interval As required
Maintenance
Maintenance
Check Mower Blades
Service Interval Before each use or daily
Check Seat Belt
Check Safety Interlock System
Check Rollover Protections Systems Roll Bar Pins
Service Air Cleaner
Check Hydraulic Oil Level
Service Interval After the first 5 hours
Service Interval Every 40 hours
Change Engine Oil
Service Interval: Every 40 hours
Check Condition Of Belts
Lubricate Grease Fittings
Maintenance
Lubricate Brake Handle Pivot
Wheel Hub - Slotted Nut Torque Specification
Service Interval Every 160 hours
Lubricate Caster Wheel Hubs
Drain Fuel Filter/Water Separator
Service Interval After the first 250 hours
Every 250 hours/Yearly if using Mobil 1 15W50
Lubricate Motion Control Bronze Bushings
Service Interval Before each use or daily
Check Engine Coolant Level
Change Engine Coolant
Maintenance
Maintenance
Service Interval Every 50 hours
Check Spark Arrester if equipped
Thread Locking Adhesives
Dielectric Grease
Adjustments
Mobil HTS Grease Or Food-Grade Anti-seize
Copper-Based Anti-seize
Maintenance
Mule Drive Belt Tension Adjustment
Pump Drive Belt Tension
Deck Belt Tension
Alternator Belt Tension
Belt Guide Adjustment
Parking Brake Adjustment
Service Interval After the first 100 hours
5.Remove the rear tires from the machine
Maintenance
Maintenance
Electric Clutch Adjustment
Removing the Shim
Motion Control Linkage Adjustment
Reverse Indicator Adjustment
Maintenance
because of the jumper wire being used. Run
Maintenance
Caster Pivot Bearings Pre-LoadAdjustment
Motion Control Damper Adjustment
Maintenance
Clean the Radiator
Cleaning
Clean Engine Cooling System
Clean Engine and Exhaust System Area
Waste Disposal
Clean Debris From Machine
Clean Grass Build-UpUnder Deck
Battery Disposal
Troubleshooting
Troubleshooting
Corrective Action
Troubleshooting
Problem
Possible Cause
Corrective Action
Troubleshooting
Problem
Possible Cause
Schematics
Schematics
Electrical Diagram
Schematics
Electrical Schematic
Owner’s Responsibilities
Exmark Commercial Turf Equipment
2 Year Limited Warranty
Instructions for Obtaining Warranty Service
Page
Page
Description of Work Done
Service Record
Service Done By
Date
Page
This page may be copied for personal use
OUT-FRONTRIDING ACCESSORIES AND OPTIONS
MID-MOUNTRIDING ACCESSORIES AND OPTIONS
WALK-BEHINDACCESSORIES AND OPTIONS