Manuals / Exmark / Household Appliance / Vacuum Cleaner

Exmark 000 & higher, 920 manual

Models: 920 000 & higher

1 60

Download 60 pages 42.39 Kb

Page 56

Image 56

Notes:

Page 56

Image 56

Contents

Part No. 4500-919Rev. A LAZER Z D-SERIESFor Serial Nos 920,000 & Higher Lazer Z LZD Units CALIFORNIA Proposition 65 Warning Introduction Model No Serial NoContents Safety Safety Alert SymbolSafety Safe Operating PracticesSafety DANGEROperation DANGER Slope OperationSafety Using the Rollover Protection System ROPS Maintenance and StorageSafety Do Not wear seat belt when the roll bar is downSafety Always shield eyes and face from batteryDANGER DANGERSafety Hydraulic fluid escaping under pressure can penetrate skin and cause injury. Fluid accidentally injected into the skin must be surgically removed within a few hours by a doctor familiar with this form of injury or gangrene may resultSafety and Instructional Decals Safety103-2076 Safety103-0223 103-0261 109-1399 Safety109-0872 Safety 109-2264 109-2478Safety 116-0127 116-0404116-3303 117-2718Safety 19426-87881107-9866 FastSpecifications SpecificationsSafety Interlock System Model NumbersSeat Hydrostatic Ground Drive SystemTires & Wheels Cutting DeckDimensions Curb WeightTorque Requirements Overall WidthProduct Overview OperationControls OperationIgnition Switch Tracking Adjustment KnobBrake Lever Hour MeterPTO Engagement Switch Coolant Temperature GaugeGlow Plug Switch and Light Pre-StartOperating Instructions Biodiesel ReadyRaise the Rollover Protection System ROPS Open the Fuel Shut-OffValveEngaging the PTO Disengaging the PTOStopping the Engine OperationAdjusting the Cutting Height Driving the MachineUse caution when making turns OperationAdjusting the Anti-ScalpRollers OperationTransporting Transporting a UnitLoading a Unit OperationMaintenance MaintenanceRecommended Maintenance Schedules Periodic Maintenance Check Battery ChargeService Interval Before each use or daily Service Interval MonthlyRecommended Jump Starting Procedure Service Interval As requiredMaintenance DANGERService Interval Before each use or daily Check Mower BladesMaintenance Check Safety Interlock System Check Rollover Protections Systems Roll Bar PinsService Air Cleaner Check Seat BeltService Interval After the first 5 hours Service Interval Every 40 hoursChange Engine Oil Check Hydraulic Oil LevelCheck Condition Of Belts Lubricate Grease FittingsMaintenance Service Interval: Every 40 hoursWheel Hub - Slotted Nut Torque Specification Service Interval Every 160 hoursLubricate Caster Wheel Hubs Lubricate Brake Handle PivotService Interval After the first 250 hours Every 250 hours/Yearly if using Mobil 1 15W50Lubricate Motion Control Bronze Bushings Drain Fuel Filter/Water SeparatorCheck Engine Coolant Level Change Engine CoolantMaintenance Service Interval Before each use or dailyService Interval Every 50 hours Check Spark Arrester if equippedThread Locking Adhesives MaintenanceAdjustments Mobil HTS Grease Or Food-Grade Anti-seizeCopper-Based Anti-seize Dielectric GreaseMule Drive Belt Tension Adjustment Pump Drive Belt TensionDeck Belt Tension MaintenanceBelt Guide Adjustment Parking Brake AdjustmentService Interval After the first 100 hours Alternator Belt TensionMaintenance 5.Remove the rear tires from the machineRemoving the Shim Electric Clutch AdjustmentMaintenance Maintenance Reverse Indicator AdjustmentMotion Control Linkage Adjustment Maintenance because of the jumper wire being used. RunMaintenance Motion Control Damper AdjustmentCaster Pivot Bearings Pre-LoadAdjustment Cleaning Clean Engine Cooling SystemClean Engine and Exhaust System Area Clean the RadiatorClean Debris From Machine Clean Grass Build-UpUnder DeckBattery Disposal Waste DisposalTroubleshooting TroubleshootingTroubleshooting ProblemPossible Cause Corrective ActionTroubleshooting ProblemPossible Cause Corrective ActionElectrical Diagram SchematicsSchematics Electrical Schematic SchematicsExmark Commercial Turf Equipment 2 Year Limited WarrantyInstructions for Obtaining Warranty Service Owner’s ResponsibilitiesPage Page Service Record Service Done ByDate Description of Work DonePage This page may be copied for personal use WALK-BEHINDACCESSORIES AND OPTIONS MID-MOUNTRIDING ACCESSORIES AND OPTIONSOUT-FRONTRIDING ACCESSORIES AND OPTIONS