Manuals / Generac / Lawn and Garden / Portable Generator

Generac 004692-0 owner manual Exploded Views and Parts Lists, Generac Power Systems, Inc

Models: 004692-0

1 44

Download 44 pages 41.05 Kb

Page 36

Image 36

Section 8 — Exploded Views and Parts Lists

Air-cooled 8.5 kW Generator

Engine – Drawing No. 0D8674-C Part 2

138

122 124

125			139
		136	135

123
	120	137

124

125

133 134

86 85

117

130

94 97 98 99

119

114

121

118

97 98

100

112

101

131	132
131
	115 116
	127
	128
	129
126

102

103	109
105
104	110
	106

107	112

108

112

113

111

34 Generac® Power Systems, Inc.

Page 36

Image 36

Generac 004692-0 owner manual Exploded Views and Parts Lists, Generac Power Systems, Inc

Contents

Installation and Owner’s Manual POWER SYSTEMS, INCDEADLY EXHAUST FUMES OUTDOOR INSTALLATION ONLY DANGERCONTENTS OPERATION AND MAINTENANCEHOW TO OBTAIN SERVICE INTRODUCTIONIntroduction GENERAL HAZARDS DANGERSAVE THESE INSTRUCTIONS – The manufacturerELECTRICAL HAZARDS FIRE HAZARDSEXPLOSION HAZARDS STANDARDS INDEX1.3 SYSTEM SET LED 1.1UNPACKING/INSPECTION1.2PROTECTION SYSTEMS Exhaust Enclosure Fuel Regulator 12 Volt Battery 1.4YOUR GENERATORData Decal1.5SPECIFICATIONS 1.5.1 GENERATOR1.5.2 ENGINE Section 1 - General Information1.8RECONFIGURING THE FUEL SYSTEM 1.6FUEL REQUIREMENTS AND RECOMMENDATIONS1.7FUEL CONSUMPTION Figure 1.2 – Demand Regulator1.10 BATTERY INSTALLATION 1.11 THE BATTERY1.9.2 TRANSFER SWITCH Figure 1.5 – Battery Cable Connections2.2CHECK TRANSFER SWITCH OPERATION 2.1BEFORE INITIAL START-UP2.3ELECTRICAL CHECKS •Wear rubber gloves and boots2.4GENERATOR TESTS UNDER LOAD DANGERDANGER DANGER2.6ADJUSTING THE REGULATOR NATURAL GAS ONLY Figure 2.2 — Placement of Regulator2.5CHECKING AUTOMATIC OPERATION Figure 2.1 — Dual Fuel Regulators2.7ENGINE GOVERNOR ADJUSTMENT 2.8VOLTAGE REGULATOR ADJUSTMENTFigure 2.4 — Full Load Speed Adjust Screw Figure 2.5 – Voltage Adjustment Potentiometer3.1 BREAK-INPROCEDURE 3.3AUTOMATIC TRANSFER OPERATION3.2.3 “MANUAL” POSITION 3.2.1 “AUTO” POSITIONFigure 3.2 – Manual Transfer Switch Operation 3.5.1 TRANSFER TO GENERATOR POWER SOURCE3.4SEQUENCE OF AUTOMATIC OPERATION 3.5MANUAL TRANSFER OPERATION3.6SETTING THE EXERCISE TIMER 3.5.2 TRANSFER BACK TO UTILITY POWER SOURCE3.7.1 LOW OIL PRESSURE SWITCH 3.7.2 HIGH TEMPERATURE SWITCH4.2CHECKING THE ENGINE OIL LEVEL 4.1FUSE3.7.3.1 Approximate Crank Cycle Times 3.7.4 OVERSPEED4.5CHANGING THE ENGINE AIR CLEANER 4.3.2 OIL CHANGE PROCEDURE4.3CHANGING THE ENGINE OIL 4.4CHANGING THE OIL FILTER4.7BATTERY MAINTENANCE Figure 4.4 — 12 kW and 15 kW Engine Air CleanerFigure 4.5 – Setting the Spark Plug Gap 4.6SPARK PLUGS4.8 ADJUSTING VALVE CLEARANCE Figure 4.6 - Valve Clearance Adjustment4.9COOLING SYSTEM Figure 4.7 – Cooling Vent Locations4.11 OUT OF SERVICE PROCEDURE 4.11.2 RETURN TO SERVICE4.11.1 REMOVAL FROM SERVICE 4.10 ATTENTION AFTER SUBMERSION4.13 SERVICE SCHEDULE 5.1TROUBLESHOOTING GUIDE PROBLEMCAUSE CORRECTION6 - Mounting Dimensions Generac Power Systems, IncAir-cooled8.5 kW Generator Drawing No. 0D3739-A REAR VIEWWiring Diagram - Drawing No. 0D8500 24 Generac Power Systems, IncSection 7 — Electrical Data Air-cooled8.5 kW GeneratorGenerac Power Systems, Inc. Section 7 — Electrical DataCUSTOMER CONNECTIONElectrical Schematic - Drawing No. 0D8501 26 Generac Power Systems, IncSection 7 — Electrical Data Air-cooled8.5 kW GeneratorGenerac Power Systems, Inc. Section 7 — Electrical DataSection 8 — Exploded Views and Parts Lists 28 Generac Power Systems, IncAir-cooled8.5 kW Generator Compartment - Drawing No. 0D8445-ASection 8 — Exploded Views and Parts Lists PART NODESCRIPTION PART NO30 Generac Power Systems, Inc Air-cooled8.5 kW GeneratorEngine & Alternator – Drawing No. 0D8446 Section 8 — Exploded Views and Parts Lists ITEMPART NO DESCRIPTIONSection 8 — Exploded Views and Parts Lists Air-cooled8.5 kW GeneratorEngine – Drawing No. 0D8674-CPart Section 8 - Exploded Views and Parts Lists PART NODESCRIPTION DESCRIPTIONSection 8 — Exploded Views and Parts Lists 34 Generac Power Systems, IncSection 8 — Exploded Views and Parts Lists PART NODESCRIPTION DESCRIPTIONSection 8 — Exploded Views and Parts Lists Control Panel Assembly – Drawing No. 0D8503-B36 Generac Power Systems, Inc Air-cooled8.5 kW GeneratorSection 8 — Exploded Views and Parts Lists PART NODESCRIPTION DESCRIPTIONSection 8 - Exploded Views and Parts Lists PART NODESCRIPTION PART NOSection 8 — Exploded Views and Parts Lists FOR GTENGINE ONLY DESCRIPTIONYOUR WARRANTY RIGHTS AND OBLIGATIONS PURCHASER’S/OWNER’S WARRANTY RESPONSIBILITIES1-800-333-1322 CALIFORNIA EMISSION CONTROL WARRANTY STATEMENTEMISSION CONTROL SYSTEM WARRANTY EMISSION RELATED PARTS INCLUDE THE FOLLOWINGSection 9 – Warranty WARRANTY SCHEDULE Section 9 – WarrantyGENERAC POWER SYSTEMS, INC P.O. BOX WHITEWATER, WI