GSI Outdoors PNEG-552 service manual Inspect the Metering Rolls, Set Control Switches

5. Dryer Pre-Start Checks

Before the dryer is filled, thoroughly inspect the unit and check the operation of the dryer as follows.

Inspect the Metering Rolls

Figure 5A Asco Safety Shut Off Valve

Open all metering roll access doors and inspect each compartment for any bolts, nuts or other foreign material, that may cause possible jamming of the metering rolls.

Before attempting to operate the dryer make sure all safety shields are in place, all bottom clean-out and rear access doors are closed and all personnel are clear of the dryer.

Set Control Switches

Moisture Control Switch	OFF
Moisture Control Thermostat	200°
Load Switch	OFF
Unload Switch	OFF
Fan Switch	OFF
Burner Switch	OFF
Out of Grain Timer	1 MINUTE (Reset to 8 Minutes after testing)
Load Delay	30 SECONDS
Unload Delay	30 SECONDS
Metering Roll Speed	LOW AND HIGH SPEED SETTINGS PUT ON ZERO
Dry Timer	60 MINUTES
Cool Timer	20 MINUTES
Unload Timer	10 MINUTES
Mode Switch	CONTINUOUS FLOW

22

PNEG-552100 Series Dryer