Place Remaining Lava Rock | Hearth and Home Technologies CARDOG42I

• Place left center log in the indentations on the front left	F. Place Remaining Lava Rock
log and the top left log as shown in Figure 8.9.	• After logs have been placed spread the remainder of the
	• After logs have been placed spread the remainder of the
	lava rock to cover the ﬂoor of the ﬁrebox.
	lava rock to cover the ﬂoor of the ﬁrebox.

Figure 8.9 Place Left Center Log

•Place the center log on the indentations of the right front log and the back log as shown in Figure 8.10.

Figure 8.10 Place Center Log

•Place the right center long on the indentations of the right front log and the right rear log as shown in Figure 8.11.

Figure 8.11 Place Right Center Log

Outdoor Lifestyles by Hearth & Home Technologies Inc. • Carolina • 4066-300 • Rev. Q • 7/11

21

Image 21

Hearth and Home Technologies CARDOG42I, CARODG36I Place Remaining Lava Rock, Log and the top left log as shown in Figure

Contents

CARODG36I CARODG36IL CARODG42I CARODG42IL Listing Label Information/Location Congratulations Table of Contents Listing and Code Approvals If this ﬁreplace is to be installed within a wall, you must Design and Installation ConsiderationsGetting Started Tools and Supplies Needed Built-in Installation Stand-Alone InstallationFraming and Clearances Select Appliance Location 1448 mm Minimum Clearances and Framing Dimensions CARODG36I, CARODG36IL Not be placed between Fireplace opening Ceiling/overhang Fireplace Securing and Leveling Appliance Appliance PreparationFlashing Position, level, and secure the appliance Gas Information Control Box Access PanelFuel Conversion Gas Pressure Connect Incoming Gas Line to Manual Shutoff Valve Valve Access Electrical Information IntelliFire Plus Pilot Ignition System Wiring Control Module Operation Nine Hour Safety Shutdown Feature Match holes Installing the Optional Electric Kit Assemble the junction box Wire the GFI receptacle as shown below Facing Material Mantel Projections Install Lava Rock Pilot ShieldPositioning the Logs Notch against grate CAROLINA-42 Place Remaining Lava Rock Place left center log in the indentations on the front leftLog and the top left log as shown in Figure Insert Rod Install Firescreen Operating Instructions Gas Fireplace SafetyYour Fireplace Screens Before Lighting Fireplace Final inspection by Lighting the Appliance After the Appliance is Lit Initial Break-in Procedure IntelliFire Plus Ignition System Troubleshooting Symptom Possible Cause Corrective Action Troubleshooting Risk of injury or property damage Before servicing Maintaining and Servicing the Appliance Inspect Maintenance Tasks Maintenance and Service Tasks Reference Materials Appliance Dimension Diagram CARODG42I, CARODG42IL Service Parts List Log Set Assembly#15 Non Combustible Board Part number list on following At Depot Stocked #14 Non Combustible Board CARODG42I, CARODG42IL Patch Kit, Fiber Additional service part numbers appear on followingTouch up Paint, Fiber Conversion Kit NG #15 Valve Assembly Outdoor Lifestyles Warranty 2108-975A 10/05/09 Warranty Limitations of Liability Contact Information