Henny Penny CW-216, CW-114 warranty OPERATING CONTROLS Continued

Model CW-216/CW-114

3-2. OPERATING CONTROLS (Continued)

Fig.	Item
No.	No.	Description	Function
3-1	1	Water valve	An electrical solenoid valve energized by the float switch or the
			water control switch (in manual position); when open, it allows
			water to flow into the water pan
3-1	2	Water strainer	A filter to prevent particles from plugging the water valve
3-1	3	Contactor	The relay that directs power to the water heaters
3-1	4	Relay	Shuts the heat off to the water pan when a low water
			condition is sensed by the float switch
3-2	5	Radiant heater	A long tubular heater mounted in a reflector located in the ceiling
			panel of the unit
3-3	6	Hi-limit thermostat	A safety device mounted to the bottom of the water pan which
			detects an over temperature condition if the water pan runs dry
3-4	8	Water pan insert	Holds the pans in place over the water
3-5	9	Pan support-top	Tilts the pans used in the top toward the customer side of the unit
3-6	10	Lightbulb	A 60 watt rated long-life bulb that should be replaced by a bulb of
			the same rating
3-7	11	Lamp socket	A high temperature ceramic socket for holding the light bulb
3-8	12	Tinted glass panel	Specially tempered colored glass with a thin film of silicone that
			protect the light bulbs and colors the light
3-9	13	Water control switch	A three-position switch on which the center position is off; in the
			position markedAUTOMATIC (up), water level in the unit will
			be controlled by the float switch; in the position marked MANUAL
			(down), water valve is opened directly by the switch; the
			MANUAL position is spring loaded so that the water valve will
			close when the switch is released
3-9	14	Water light	A light, operated directly by the float switch, that indicates low
			water conditions, regardless of the position of the water control
			switch; the low water level is indicated when the light is illuminated
3-9	15	Thermometer	Indicates the water temperature
3-9	16	Water Thermostat	An electro-mechanical device used to regulate the water
			temperature
3-9	17	Power Switch	A two-position, three pole switch used to turn on and off the heat
			and water control systems

3-4 1107