Manuals / Hustler Turf / Lawn and Garden / Lawn Mower Accessory

Hustler Turf 3700, 3500 owner manual Maintenance Locator Chart, 4-19

Models: 3700 3500

1 52

Page 47

MAINTENANCE LOCATOR CHART

16		15

1. Engine Oil Fill

2. Engine Air Cleaner

3. Radiator Cap

4. HST Filter

5. Hydraulic Oil Filter

6. Engine Oil Filter & Dipstick

7. Wheels & Tires

8. Fuel Filter

9. Battery

10. Fan Belt

11. Transmission Oil Fill

12. Lift Arm

13. Lift Cylinder

14. Brake Pedal Shaft

15. Power Steering Cylinder

16. Differential Lock Pedal Shaft

17. Rear Axle 4WD Oil Fill/Dipstick

18. Radiator Screen

Figure 4-40

109627_0910

4-19

Page 47

Image 47

Hustler Turf 3700, 3500 owner manual Maintenance Locator Chart, 4-19

Contents

67062-2097 Hustler 3500/3700 Owner’s ManualP.O. Box Hesston, KansasInspect spark arrester daily replace every 500 hours or as needed 1096270910Parts and service Using this manualWarranty registration Tractor gross vehicle weight GVW1096270910 WHAT IS NOT COVERED BY THIS WARRANTY TWO YEAR 1500 HOURS LIMITED WARRANTYWHAT IS COVERED BY THIS WARRANTY WHO MUST PERFORM THE WARRANTY SERVICE1096270910 WARRANTY REGISTRATION3. The date of purchase constitutes delivery Safety and Instruction Decals SAFETY PRECAUTIONSWARNING Rotating fan blade DANGER Battery HazardsWARNING Hot surface WARNING Hot fluid under pressuredecals before attempting to operate or service this machineWARNING Read Owner’s Manual and WARNING Rotating driveshaftWARNING Ejection 601415 WARNING RolloverWARNING Back over WARNING RolloverHours Recorded INTERNATIONAL SYMBOLSBattery Power Take-off ON Power Take-off OFF Slow Fast Control Lever Volume Empty1096270910 Slope Guide Lines Use this diagram when determining the degree of slope to be mowedSLOPE GUIDE E 15 o1096270910 Operation OPERATIONSafe Operating Practices Slope Operation Using a rampInstrument Panel SwitchesChildren Controls High range C Park brake lever Release buttonD Differential lock pedal Safety start interlock system Seat adjustmentSteering wheel adjustment The engine should continue to run To inspect the safety start interlock systemPTO stop system To inspect the PTO stop systemStarting the engine with jumper cables Engine startingWarm weather starting Cold weather startingHydrostatic transmission Stopping the engineOperating the hydrostatic transmission and PTO Engine warm upAutomatic or Locked All Wheel Drive AWD Power take-off operationWeight transfer valve Auxiliary hydraulic valve kit optionalROPS Roll Over Protective Structure Rear counter-balance weightsPossible damage to the ROPS Operating suggestions Driving the tractor3-14 1096270910Introduction MAINTENANCE & ADJUSTMENTSService Safe Servicing PracticesLubrication Service accessTorque values TiresHood latch AlternatorFuse block Head lamp Replacement bulbReplacement bulbs Fusible linkFuel system IMPORTANT Do not fill tank to capacity. Allow room for expansion Diesel fuelRefueling the Tractor Bleeding the fuel system Engine oil and filterFuel filter Draining the fuel filter Changing the fuel filterOverservicing Recommended service procedureEngine air filter Draining and flushing the cooling system Cooling systemChecking the coolant level To adjust fan belt tension To drain the cooling systemFan belt Changing Oil & Filters Transmission, front axle and hydraulic systemChecking Oil Level Change the oil every 500 hours or annually PTO control lever adjustmentPark brake adjustment General engine maintenanceRear wheel toe adjustment tractor Adjustable tie-rodFront of 4-16 1096270910Every 3500/3700 Maintenance Schedule Refer to Figures 4-39SERVICE AT First1096270910 MAINTENANCE LOCATOR CHART4-19 MAINTENANCE LOCATOR CHART4-20 1096270910New season preparation STORAGEPRODUCT LITERATURE Preparation of engine for storage1096270910 PAGE INDEXPAGE Maintenance & Adjustments Introduction1096270910