Manuals
/
Jackson
/
Kitchen Appliance
/
Dishwasher
Jackson
JP-24BF, jp-24b, JP-24F
technical manual
Section Installation/Operation Instructions
Models:
JP-24F
JP-24BF
JP-24
jp-24b
1
10
59
59
Download
59 pages
5.55 Kb
7
8
9
10
11
12
13
14
Troubleshooting
Install
Section Electrical Schematics
Dimension
Maintenance
Common Problems
Gauge Panel Assembly
Phase
Section Service Procedures
Coil & Housing only, 1/2”
Page 10
Image 10
SECTION 2:
INSTALLATION/OPERATION
INSTRUCTIONS
5
Page 9
Page 11
Page 10
Image 10
Page 9
Page 11
Contents
HOT WATER SANITIZING UNDERCOUNTER DISHMACHINES
TECHNICAL MANUAL
FOR JACKSON MODELS JP-24 JP-24F JP-24B JP-24BF
March 6 P/N 7610-002-49-79 Revision D
Page
APPLICABLE
REVISION
MADE
DETAILS
NOMENCLATURE FOR THE MODELS COVERED IN THIS MANUAL
Model Serial No Installation Date Service Rep. Name Phone No
JP-24B
II. INSTALLATION/OPERATION INSTRUCTIONS
TABLE OF CONTENTS
I. SPECIFICATION INFORMATION
PREVENTATIVE MAINTENANCE
SECTION SPECIFICATION INFORMATION
5 MINUTE TIMER OPERATING CYCLE SECONDS
SECTION 1 SPECIFICATION INFORMATION
SPECIFICATIONS of the JP-24/JP-24F
PERFORMANCE/CAPABILITIES OPERATING CAPACITY RACKS/HOUR
SPECIFICATIONS of the JP-24B/JP-24BF
5 MINUTE TIMER OPERATING CYCLE SECONDS WASH TIME
30.5 cm
JP-24 DIMENSIONS
DIMENSIONS
22 5/8”
SECTION INSTALLATION/OPERATION INSTRUCTIONS
SECTION 2 INSTALLATION/OPERATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS
ELECTRICAL INSTALLATION INSTRUCTIONS
OPERATION INSTRUCTIONS
DETERGENT CONTROL
CYCLE COUNTER RETROFIT KIT INSTRUCTIONS
SECTION PREVENTATIVE MAINTENANCE
SECTION 3 PREVENTATIVE MAINTENANCE
SECTION TROUBLESHOOTING
Problem Water overflow from bottom of door
SECTION 4 TROUBLESHOOTING SECTION
COMMON PROBLEMS
Problem Wash motor doesn’t operate on manual wash
Problem No indication of pressure
Problem Machine doesn’t drain when “OFF/DRAIN” switch is pressed
Problem Rinse water not at required temperature range
SECTION SERVICE PROCEDURES
PREPARATION
SECTION 5 SERVICE PROCEDURES
RINSE SOLENOID VALVE REPAIR PARTS KIT
TOOLS REQUIRED
RINSE SOLENOID VALVE REPAIR PARTS KIT CONTINUED
13. Slowly remove the valve bonnet. Note The spring for the plunger is located directly under the bonnet and may come free if you are not careful. Remove the plunger, spring and valve bonnet and place to the side
SPECIAL PARTS
AFTER MAINTENANCE ACTIONS
Solenoid Valve Plunger Kit Includes plunger and spring Part number
VACUUM BREAKER REPAIR PARTS KIT
VACUUM BREAKER REPAIR PARTS KIT CONTINUED
REPLACING THE BOOSTER TANK HEATER
REPLACING THE PUMP MOTOR/REPLACING THE HEATER
REPLACING THE PUMP MOTOR
Heater
MINAL ON THE MOTOR
REPLACING THE DRAIN VALVE REPLACING THE DRAIN VALVE
Replacing the Drain Valve
RINSE REGULATING THERMOSTAT REPLACEMENT
Remove the thermostat bracket mounting nuts with the 3/8” nutdriver
9. Note regardless of the unit this is being done to, the con- cept is to ensure that the thermostat cannot come into contact with the heater leads or interfere with the placement of any covers
SPECIAL NOTES
SECTION PARTS SECTION
ITEM QTY DESCRIPTION
GAUGE PANEL ASSEMBLY
SECTION 6 PARTS SECTION
Mfg. No
ELECTRICAL PANEL ASSEMBLY JP-24/F 208-240 VOLT
DESCRIPTION
ELECTRICAL PANEL ASSEMBLY JP-24B/BF 208-240 VOLT
ELECTRICAL PANEL ASSEMBLY JP-24B/BF 460 VOLT
AMTRAK External Control Box Option
This panel is used with the following External Control Box Option
Mfg. No
INSIDE VIEW of AMTRAK & EXTERNAL OPTIONS
ELECTRICAL PANEL ASSEMBLY EXTERNAL OPTION & AMTRAK OPTION
FRONT VIEW EXTERNAL OPTION
RIGHT SIDE VIEW AMTRAK OPTION
ELECTRICAL PANEL ASSEMBLY EXTERNAL OPTION & AMTRAK OPTION CONTINUED
Nut, Nylon Wing, 1/4”-20 Control Panel Assembly 05700-011-40-93
KICK PLATE ASSEMBLY
Decal, Power Disconnect Warning 09905-021-47-07
Control Panel Only 460 Control Panel Assembly 05700-002-18-38
Vacuum Breaker Assembly
INCOMING PLUMBING ASSEMBLY JP-24/JP-24F
INCOMING PLUMBING ASSEMBLIES JP-24B/JP-24BF
RINSE STIFFENER/RINSE HUB WELDMENT
Connects to Rinse Injector Connects to Rinse Stiffener
Complete 220 Volt Solenoid Valve Assembly, 1/2”
Complete 110 Volt Solenoid Valve Assembly, 1/2”
Coil & Housing only, 1/2”
Complete Vacuum Breaker Assembly, 1/2” NPT
DRAIN VALVE ASSEMBLY
SECTION 6 PARTS SECTION
DRAIN PLUMBING ASSEMBLY
WASH MOTOR TO WASH TUB ASSEMBLY
JP-24B/BFRINSE TANK
Phase
RINSE TANK & COMPONENTS/STRIP HEATER KIT
40F Rise
DOOR ASSEMBLY
Order this entire assembly using
Door Latch Assembly
MISCELLANEOUS DOOR SUB-ASSEMBLIES
Rinse Arm Assembly
Wash Arm Assembly
RINSE ARM & WASH ARM ASSEMBLIES
FRAME & PANEL COMPONENTS/MISCELLANEOUS PARTS
CYCLE COUNTER RETROFIT KIT
SECTION ELECTRICAL SCHEMATICS
SECTION 7 ELECTRICAL SCHEMATICS
JP-24/JP-24F 208-230 VOLT - 50/60 HERTZ - SINGLE PHASE
JP-24B/JP-24BF 208-230 VOLT - 50/60 HERTZ - SINGLE PHASE
JP-24B/JP-24BF 460 VOLT - 60 HERTZ - THREE PHASE
Top
Page
Image
Contents
