JP-24B/JP-24BF 460 VOLT - 60 HERTZ - THREE PHASE | Jackson JP-24F

JP-24B/JP-24BF 460 VOLT - 60 HERTZ - THREE PHASE

SECTION 7: ELECTRICAL SCHEMATICS

JP-24B/JP-24BF 460 VOLT - 60 HERTZ - THREE PHASE

JP-24 Technical Manual 7610-002-49-79 Rev. D

Issued: 03-06-2006 Revised: N/A

54

Image 59

Jackson JP-24F JP-24B/JP-24BF 460 VOLT - 60 HERTZ - THREE PHASE, Electrical Schematics, Issued 03-06-2006 Revised N/A

Contents

March 6 P/N 7610-002-49-79 Revision D TECHNICAL MANUALFOR JACKSON MODELS JP-24 JP-24F JP-24B JP-24BF HOT WATER SANITIZING UNDERCOUNTER DISHMACHINESPage DETAILS REVISIONMADE APPLICABLE JP-24B Model Serial No Installation Date Service Rep. Name Phone NoNOMENCLATURE FOR THE MODELS COVERED IN THIS MANUAL PREVENTATIVE MAINTENANCE TABLE OF CONTENTSI. SPECIFICATION INFORMATION II. INSTALLATION/OPERATION INSTRUCTIONS SECTION SPECIFICATION INFORMATION PERFORMANCE/CAPABILITIES OPERATING CAPACITY RACKS/HOUR SECTION 1 SPECIFICATION INFORMATIONSPECIFICATIONS of the JP-24/JP-24F 5 MINUTE TIMER OPERATING CYCLE SECONDS 5 MINUTE TIMER OPERATING CYCLE SECONDS WASH TIME SPECIFICATIONS of the JP-24B/JP-24BF 22 5/8” JP-24 DIMENSIONSDIMENSIONS 30.5 cm SECTION INSTALLATION/OPERATION INSTRUCTIONS INSTALLATION INSTRUCTIONS SECTION 2 INSTALLATION/OPERATION INSTRUCTIONS ELECTRICAL INSTALLATION INSTRUCTIONS OPERATION INSTRUCTIONS DETERGENT CONTROL CYCLE COUNTER RETROFIT KIT INSTRUCTIONS SECTION PREVENTATIVE MAINTENANCE SECTION 3 PREVENTATIVE MAINTENANCE SECTION TROUBLESHOOTING Problem Wash motor doesn’t operate on manual wash SECTION 4 TROUBLESHOOTING SECTIONCOMMON PROBLEMS Problem Water overflow from bottom of door Problem Rinse water not at required temperature range Problem Machine doesn’t drain when “OFF/DRAIN” switch is pressedProblem No indication of pressure SECTION SERVICE PROCEDURES TOOLS REQUIRED SECTION 5 SERVICE PROCEDURESRINSE SOLENOID VALVE REPAIR PARTS KIT PREPARATION RINSE SOLENOID VALVE REPAIR PARTS KIT CONTINUED 13. Slowly remove the valve bonnet. Note The spring for the plunger is located directly under the bonnet and may come free if you are not careful. Remove the plunger, spring and valve bonnet and place to the side Solenoid Valve Plunger Kit Includes plunger and spring Part number AFTER MAINTENANCE ACTIONSSPECIAL PARTS VACUUM BREAKER REPAIR PARTS KIT VACUUM BREAKER REPAIR PARTS KIT CONTINUED Heater REPLACING THE PUMP MOTOR/REPLACING THE HEATERREPLACING THE PUMP MOTOR REPLACING THE BOOSTER TANK HEATER Replacing the Drain Valve REPLACING THE DRAIN VALVE REPLACING THE DRAIN VALVEMINAL ON THE MOTOR RINSE REGULATING THERMOSTAT REPLACEMENT Remove the thermostat bracket mounting nuts with the 3/8” nutdriver 9. Note regardless of the unit this is being done to, the con- cept is to ensure that the thermostat cannot come into contact with the heater leads or interfere with the placement of any covers SPECIAL NOTES SECTION PARTS SECTION Mfg. No GAUGE PANEL ASSEMBLYSECTION 6 PARTS SECTION ITEM QTY DESCRIPTION DESCRIPTION ELECTRICAL PANEL ASSEMBLY JP-24/F 208-240 VOLT ELECTRICAL PANEL ASSEMBLY JP-24B/BF 208-240 VOLT ELECTRICAL PANEL ASSEMBLY JP-24B/BF 460 VOLT Mfg. No This panel is used with the following External Control Box OptionAMTRAK External Control Box Option RIGHT SIDE VIEW AMTRAK OPTION ELECTRICAL PANEL ASSEMBLY EXTERNAL OPTION & AMTRAK OPTIONFRONT VIEW EXTERNAL OPTION INSIDE VIEW of AMTRAK & EXTERNAL OPTIONS ELECTRICAL PANEL ASSEMBLY EXTERNAL OPTION & AMTRAK OPTION CONTINUED Control Panel Only 460 Control Panel Assembly 05700-002-18-38 KICK PLATE ASSEMBLYDecal, Power Disconnect Warning 09905-021-47-07 Nut, Nylon Wing, 1/4”-20 Control Panel Assembly 05700-011-40-93 INCOMING PLUMBING ASSEMBLY JP-24/JP-24F Vacuum Breaker Assembly INCOMING PLUMBING ASSEMBLIES JP-24B/JP-24BF Connects to Rinse Injector Connects to Rinse Stiffener RINSE STIFFENER/RINSE HUB WELDMENT Complete Vacuum Breaker Assembly, 1/2” NPT Complete 110 Volt Solenoid Valve Assembly, 1/2”Coil & Housing only, 1/2” Complete 220 Volt Solenoid Valve Assembly, 1/2” SECTION 6 PARTS SECTION DRAIN VALVE ASSEMBLY DRAIN PLUMBING ASSEMBLY WASH MOTOR TO WASH TUB ASSEMBLY 40F Rise PhaseRINSE TANK & COMPONENTS/STRIP HEATER KIT JP-24B/BFRINSE TANK Order this entire assembly using DOOR ASSEMBLY MISCELLANEOUS DOOR SUB-ASSEMBLIES Door Latch Assembly RINSE ARM & WASH ARM ASSEMBLIES Wash Arm AssemblyRinse Arm Assembly FRAME & PANEL COMPONENTS/MISCELLANEOUS PARTS CYCLE COUNTER RETROFIT KIT SECTION ELECTRICAL SCHEMATICS JP-24/JP-24F 208-230 VOLT - 50/60 HERTZ - SINGLE PHASE SECTION 7 ELECTRICAL SCHEMATICS JP-24B/JP-24BF 208-230 VOLT - 50/60 HERTZ - SINGLE PHASE JP-24B/JP-24BF 460 VOLT - 60 HERTZ - THREE PHASE