Langley/Empire DV-40E-5, DV-20E-5 installation instructions How To Order Repair Parts, Parts List

HOW TO ORDER REPAIR PARTS

Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the service person/dealer.

All parts listed in the Parts List have a Part Number. When ordering parts, first obtain the Model Number from the name plate on your equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the following appropriate illustration and list. Be sure to give all this information.

Furnace Model Number	Part Description
Furnace Serial Number	Part Number
Type of Gas (Propane or Natural)

Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store. Shipments contingent upon strikes, fires and all causes beyond our control.

Empire Comfort Systems, Inc. Nine Eighteen Freeburg Ave. Belleville, IL 62222-0529

PARTS LIST

PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.

	INDEX	PART		INDEX	PART
	NO.	NUMBER	DESCRIPTION	NO.	NUMBER	DESCRIPTION
1		DV-1378	SHROUD TOP	39	R-2575	FLAME ROLLOUT SWITCH
2		DV-1376	SHROUD SIDE RIGHT	40	DV-1038	BURNER COMPARTMENT ACCESS
3		R-2521	AIR FILTER			PANEL
4		DV-1375	FILTER RETAINER	41	DV-1039	BURNER COMPARTMENT
5		DV-1379	WALL MOUNTING BRACKET	42	R-3237	GAS VALVE (NAT GAS)
6		DV-1048	WALL BRACKET - 2 REQUIRED	42	R-3238	GAS VALVE (LP GAS)
7		R-2586	CONTROL DOOR PIN - 2 REQUIRED	43	DV-1366	VALVE BRACKET ASSEMBLY
8		19676	CONTROL DOOR ASSEMBLY	44	DV-1016	MANIFOLD ASSEMBLY (DV-20E-5 ONLY)
9		DV-1373	CASING TOP	44	DV-1013	MANIFOLD ASSEMBLY (DV-40E-5 ONLY)
10		DV-1368	BLOWER HOUSING - 2 REQUIRED	45	P-88-44	ORIFICE (NAT GAS) - 1 REQUIRED ON
11		R-2584	BLOWER WHEEL - 2 REQUIRED			DV-20E-5
12		R-2573	BLOWER MOTOR	45	P-88-55	ORIFICE (LPG GAS) - 1 REQUIRED ON
13		R-2598	MOTOR BASE WASHER - 4 REQUIRED			DV-20E-5
14		R-1279	LIMIT SWITCH	45	P-88-44	ORIFICE (NAT GAS) - 2 REQUIRED ON
15		DV-1367	INNER TOP			DV-40E-5
16		R-2546	CONTROL KNOB	45	P-88-55	ORIFICE (LPG GAS) - 2 REQUIRED ON
17		R-2522	ON/OFF SWITCH			DV-40E-5
18		19561	JUNCTION BOX	46	M-148	MANIFOLD GASKET
19		DV-1370	JUNCTION BOX COVER	47	DV-781	OBSERVATION HOLE COVER ASSEMBLY
20		R-1995	TRANSFORMER	48	M-155	OBSERVATION HOLE COVER GASKET
21		R-6989	PRESSURE SWITCH	49	DV-1040	FRONT SHIELD ASSEMBLY
22		R-8140	CONTROL BOARD	50	DV-1024	BOTTOM SHIELD
23		R-2577A	TEMPERATURE CONTROL BOARD	51	DV-1363	FRONT GRILL ASSEMBLY
24		DV-1365	CASING WELDED ASSEMBLY	52	DV-1380	CASING FRONT ASSEMBLY
25		R-1468	STRAIN RELIEF BUSHING	53	R-2539	HOSE CLAMP - 4 REQUIRED
26		R-2099	CORD SET	54	R-3113	INLET HOSE
27		DV-1371	INNER END	55	R-3111	OUTLET ELBOW
28		DV-1372	CASING SIDE - 2 REQUIRED	56	DV-1192	VENT PAN ASSEMBLY
29		15790	COLLECTOR BOX (DV-20E-5 ONLY)	57	R-3114	INLET CAP
29		15791	COLLECTOR BOX (DV-40E-5 ONLY)	58	R-3115	WALL PLATE GASKET - INSIDE
30		R-2519	INDUCER WHEEL	59	R-2587	WALL PLATE GASKET - OUTSIDE
31		DV-1169	INDUCER BLOWER HOUSING	60	DV-1195	WALL PLATE - OUTSIDE
32		R-2523	INDUCER MOTOR	61	DV-1193	TUBE SPACER
33		15783	EXCHANGER ASSEMBLY (DV-20E)	62	DV-1194	END CAP ASSEMBLY
33		15784	EXCHANGER ASSEMBLY (DV-40E)	63	DV-1377	SHROUD SIDE LEFT
34		19565	IGNITOR KIT	NS	DV-1361	BAFFLE - 1 REQUIRED ON DV-20E-5
37		R-2543	FLAME SENSOR	NS	DV-1108	CONDENSATE KIT
38		R-2541	BURNER (2 REQUIRED ON DV-40E-5)	NS	DV-1132	ELBOW KIT
				NS	R-8142	WIRE ASSEMBLY - CONTROL BOARD

19562-1-0606 Page 17