Wiring diagrams are provided here for reference purposes only. This information is also provided on schematics attached directly to the appliance on a pullout panel located within the control compartment.
CAUTION: LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONTROLS. WIRING ERRORS CAN CAUSE IMPROPER AND DANGEROUS APPLIANCE OPERATION.
Millivolt Wiring Diagram
If any of the original wire as supplied must be replaced, it must be replaced with Type AWM 105° C – 18 GA. wire.
TP | TH TP |
| TH |
Thermopile
Field Wired
Factory Wired
*OR OPTIONAL
OR OPTIONAL REMOTE CONTROL RECEIVER
*Turn the
to the OFF position if an optional control switch is installed.
Schematic Representation Only
Electronic Wiring Diagram (Honeywell) Showing the Blower Wiring for the Optional
1.If any of the original wire as supplied must be replaced,
1.it must be replaced with Type AWM 105° C – 18 GA. wire.
2.120V, 60Hz – Less than 3 amps.
**ON/OFF Switch (Integral | **Leave the ON/OFF switch, which is integral | |||
with Gas Valve) | with the gas valve, in the ON position. | |||
| Gas Valve | PILOT |
|
|
|
|
|
| |
| IGNITER | ASSEMBLY |
|
|
BK |
|
|
| |
|
|
|
| |
| R | Green |
|
|
| BL | White | Ground - Green | |
|
|
|
| Neutral - White |
| OPT |
| Black | 120 VAC - Black |
|
|
| ||
| BLOWER |
|
| Junction Box |
| Tab Intact |
|
|
|
|
|
| Tab |
|
|
|
| Broken |
|
|
|
| Red | Optional |
| Green |
|
| |
| Neutral | Hot | Accessory | |
| Ground | Side of | Side of | Switch |
| Screw | Receptacle | Receptacle |
|
W
BTransf.
| G | 120 V. |
BL |
| 24 V |
|
| |
|
| R |
W
BK
OPTIONAL
OR OPTIONAL WALL SWITCH
OR OPTIONAL THERMOSTAT
OR OPTIONAL REMOTE RECEIVER
*Blower speed control switch is provided in FBK200 blower kit.
Factory Wired | Field Wired |
Schematic Representation Only
Electronic Wiring Diagram (Honeywell) Showing the Blower Wiring for the Optional
1.If any of the original wire as supplied must be replaced,
1.it must be replaced with Type AWM 105° C – 18 GA. wire.
2.120V, 60Hz – Less than 3 amps.
*Leave the ON/OFF switch, which is integral
*ON/OFF Switch (Integral with the gas valve, in the ON position. with Gas Valve)
|
| Gas Valve |
| PILOT | Ground - Green | ||
|
|
|
|
|
| ||
|
|
|
|
|
| ASSEMBLY | |
|
|
| IGNITER |
| Neutral - White | ||
BK |
|
|
| 120 VAC - Black | |||
|
|
|
|
| |||
Optional
R
BL | Module | Green | White |
|
|
|
|
| |
OPT |
|
| Black |
|
BLOWER |
|
|
| Junction Box |
| Tab Intact |
| Tab |
|
|
|
| Broken |
|
| Green |
| Red | Optional |
|
|
| ||
| Neutral | Hot | Accessory | |
| Ground | |||
| Screw | Side of | Side of | Switch |
|
| Receptacle | Receptacle |
|
W
BTransf.
G | 120 V. |
BL | 24 V |
| |
| R |
WH
BK
OPTIONAL
OR OPTIONAL REMOTE RECEIVER
Factory Wired | Field Wired |
Schematic Representation Only
Your gas appliance is covered by a limited twenty year warranty. You will find a copy of the warranty accompanying this manual. Please read the warranty to be familiar with its coverage.
Retain this manual. File it with your other documents for future reference.
A complete parts list is found at the end of this manual. Use only parts supplied from the manufacturer.
Normally, all parts should be ordered through your Lennox distributor or dealer. Parts will be shipped at prevailing prices at time of order.
When ordering repair parts, always give the following information:
1.The model number of the appliance.
2.The serial number of the appliance.
3.The part number.
4.The description of the part.
5.The quantity required.
6.The installation date of the appliance.
We recommend that you record the following important information about your fireplace. Please contact your Lennox dealer for any questions or concerns. For the number of your nearest Lennox dealer, please call
Your Fireplace's Model Number _______________________________________
Your Fireplace's Serial Number ________________________________________
The Date On Which Your Fireplace Was Installed __________________________
The Type of Gas Your Fireplace Uses ___________________________________
Your Dealer's Name _________________________________________________
14 | NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. |
If you encounter any problems or have any questions concerning the installation or application of this system, please contact your dis- tributor, or Lennox directly:
LENNOX HEARTH PRODUCTS1110 West Taft AvenueOrange, CA 92865