Lenovo 8086, 8087, 8088, 8089, 8090, 8094 Chapter 8. Replacing FRUs

Chapter 8. Replacing FRUs

Important

Before you replace any FRU, read Chapter 2, “Safety information,” on page 5.

These precautions and guidelines will help you work safely.

FRU replacements are to be done by trained service technicians only.

This chapter does not contain a remove and replace procedure for all FRUs. Only

the major FRUs are documented.

Locating connectors on the front

The following illustration shows the locations of the USB connectors on the front of

the computer.

1Headphone connector 3USB connector

2Microphone connector 4USB connector

Contents

Main Page Page Page Contents Chapter 1. About this manual . . . . .1 Lenovo 2005, 2008. Portions IBM Corp. 2005. iii Chapter 2. Safety information . . . . .5 Chapter 3. General information . . . .41 Appendix. Notices . . . . . . . . . 155 Television output notice . . . . . . . . . . 156 Trademarks . . . . . . . . . . . . . . 156 iv Chapter 1. About this manual Lenovo 2005, 2008. Portions IBM Corp. 2005. 1 Important Safety Information Strategy for replacing FRUs for CTO, CMV, and GA V products Product definition 2 FRU Identification for CTO, CMV, and GA V products Using PEW Chapter 1. About this manual 3 Important information about replacing RoHS compliant FRUs 4 Current or original part Replacement FRU Current or original part Chapter 2. Safety information Lenovo 2005, 2008. Portions IBM Corp. 2005. 5 General safety Electrical safety 6 Safety inspection guide Chapter 2. Safety information 7 Handling electrostatic discharge-sensitive devices 8 Grounding requirements Safety notices (multi-lingual translations) Chapter 2. Safety information 9 10 Use safe practices when lifting. Chapter 2. Safety information Page Page 14 Chapter 2. Safety information 15 16 CUIDADO: Utilize procedimentos de segurana para levantar equipamentos. Chapter 2. Safety information 17 Page Page Page Page Page Chapter 2. Safety information 23 24 ATTENTION: Soulevez la machine avec prcaution. Chapter 2. Safety information 25 26 wie folgt vor Chapter 2. Safety information 27 ACHTUNG: Arbeitsschutzrichtlinien beim Anheben der Maschine beachten. 28 Page Page Page 32 Chapter 2. Safety information 33 ATTENZIONE: Prestare attenzione nel sollevare lapparecchiatura. 34 Page Page Page 38 Chapter 2. Safety information 39 PRECAUCIN: Adopte procedimientos seguros al levantar el equipo. 40 Chapter 3. General information Lenovo 2005, 2008. Portions IBM Corp. 2005. 41 The Access IBM program Additional information resources Specifications This section lists the physical specifications for your computer. 42 Chapter 4. General Checkout Lenovo 2005, 2008. Portions IBM Corp. 2005. 43 d. Observe the LEDs and refer to the following table. Power LED Green diagnostic LED Problem determination tips 44 Type and version level Print (print screen) configuration currently in use BIOS level Chapter 4. General Checkout 45 Page Chapter 5. Diagnostics using PC-Doctor for DOS Lenovo 2005, 2008. Portions IBM Corp. 2005. 47 Starting PC-Doctor from the Rescue and Recovery workspace Starting PC-Doctor from a diagnostic diskette or CD-ROM 48 Diagnostics program download Navigating through the diagnostics programs Running diagnostics tests Test selection Chapter 5. Diagnostics using PC-Doctor for DOS 49 1.The terms fixed disk and hard disk are used interchangeably. Code Test results 50 Linear Verify Random Verify Quick and Full erase - hard drive Chapter 5. Diagnostics using PC-Doctor for DOS 51 functions. Viewing the test log 52 Chapter 6. Using the Setup Utility Lenovo 2005, 2008. Portions IBM Corp. 2005. 53 Starting the Setup Utility program Viewing and changing settings Exiting from the Setup Utility program Password considerations 54 User Password Administrator Password IDE Drive User Password Setting, changing, and deleting a password Using Security Profile by Device Selecting a startup device 56 Selecting a temporary startup device Changing the startup device sequence Advanced settings Chapter 7. Symptom-to-FRU Index Lenovo 2005, 2008. Portions IBM Corp. 2005. 57 Hard disk drive boot error A hard disk drive boot error (error codes 1962 and I999030X) can have the following causes. The start-up drive is not in the boot sequence in configuration. 58 Power LED Green diagnostic LED ON OFF Replace the system board ON ON ON Replace the power supply Diagnostic error codes Chapter 7. Symptom-to-FRU Index 59 000-000-XXX BIOS Test Passed No action 000-002-XXX BIOS Timeout 60 Page 62 Page 64 Page 66 Page Diagnostic Error Code FRU/Action 015-034-XXX USB port buffer allocation failure 68 System board 015-040-XXX USB port IRQ failure No action 018-0XX-XXX PCI Card Failure 1. PCI card 2. Information only Re-start the test, if necessary Chapter 7. Symptom-to-FRU Index 69 No action 020-0XX-XXX PCI Interface error 70 Diagnostic Error Code FRU/Action 025-198-XXX IDE interface test aborted Chapter 7. Symptom-to-FRU Index 71 No action 030-00X-XXX 030-01X-XXX SCSI interface failure Diagnostic Error Code FRU/Action 030-198-XXX SCSI interface test aborted 72 No action No action 035-0XX-XXX RAID interface Failure Page 74 No action 086-001-XXX Mouse Port interface Presence 1. Mouse 2. System board 086-035-XXX Mouse Port interface Reset 1. Mouse 2. System board 086-040-XXX Mouse Port interface IRQ failure Diagnostic Error Code FRU/Action 086-197-XXX Mouse Port interface test warning Chapter 7. Symptom-to-FRU Index 75 No action No action 089-XXX-XXX Microprocessor failure 76 Page 78 Page Beep symptoms 80 Use the following table to diagnose beep symptoms. 1-1-3 CMOS read-write error 1. Run Setup 2. System Board 1-2-2-3 ROM BIOS check error Beep Symptom FRU/Action 2-2-4 CMOS configuration info validation failed Chapter 7. Symptom-to-FRU Index 81 No-beep symptoms 82 POST error codes Chapter 7. Symptom-to-FRU Index 83 If problem persists, replace the system board 162 Configuration error POST Error Code FRU/Action 191 System Security: Embedded Security hardware Reset 84 1. Check for stuck keys 2. Replace the keyboard 211 Keyboard error Page Miscellaneous error messages 86 Chapter 7. Symptom-to-FRU Index 87 Message/Symptom FRU/Action Some or all keys on the keyboard do not work 1. Keyboard 2. Keyboard Cable Undetermined problems 88 Chapter 8. Replacing FRUs Lenovo 2005, 2008. Portions IBM Corp. 2005. 89 Locating connectors on the front 2Microphone connector 4USB connector Locating the connectors on the rear 90 Opening the cover Locating components Chapter 8. Replacing FRUs 91 Identifying parts on the system board 92 Removing and replacing a memory module Removing and replacing a PCI adapter Removing and replacing the battery 94 Chapter 8. Replacing FRUs 95 6. Install the new battery. Removing and replacing the power supply 96 Removing and replacing the system board 98 Chapter 8. Replacing FRUs 99 Removing and replacing the microprocessor 100 Page Removing and replacing an optical drive 102 Removing and replacing a hard disk drive 10. Go to Completing the FRU replacement.. Completing the FRU replacement. 104 Chapter 9. FRU lists Lenovo 2005, 2008. Portions IBM Corp. 2005. 105 Machine Type 8086 106 89P6805 ** 19K1568 * 40Y8757 * 26K5427 * Chapter 9. FRU lists 107 40Y8793 * 39M3503 * 40Y8907 * 108 89P6791 ** 19R2435 ** Chapter 9. FRU lists 109 41T2092 ** 41T2094 ** 73P2684 * 12 Memory - 1 GB NP SDRAM PC3200 (models CTO) 22P9274 * 110 89P5089 * 8086 FRUs FRU# CRU Chapter 9. FRU lists 112 Chapter 9. FRU lists 114 14F0050 * Power Cord (India) (models 2BQ 36Q 41Q 1BQ) 49P2078 * Machine Type 8087 Chapter 9. FRU lists 116 Chapter 9. FRU lists 73P2684 * 12 Memory - 1 GB NP SDRAM PC3200 (models CTO) 22P9274 * 118 Chapter 9. FRU lists 120 Chapter 9. FRU lists 121 Machine Type 8088 122 Chapter 9. FRU lists 123 124 73P2684 * 12 Memory - 1GB NP SDRAM PC3200 (models CTO) 22P9274 * Chapter 9. FRU lists 125 126 Chapter 9. FRU lists 127 128 Machine Type 8089 Chapter 9. FRU lists 129 24P3665 * 4 Hard disk drive 80GB 7200rpm EIDE ATA-100 (models 71G 73G CTO 23S 23D 77G) 130 26K5407 * 6 DVD-ROM/CD-RW Combo Drive 24x24x24x8x (models 12U 22U CTO 23S 23D 32U 77G) 40Y8783 * 6 DVD-ROM/CD-RW Combo Drive 24x24x24x8x (models 12U 22U CTO 23S 23D 32U 77G) 26K5409 * 6 DVD-ROM/CD-RW Combo Drive 24x24x24x8x (models 12U 22U CTO 23S 23D 32U 77G) Chapter 9. FRU lists 131 132 Chapter 9. FRU lists 133 8089 Windows XP Home Recovery CDs FRU# CRU TR (models CTO-G) 39J6266 * 134 Machine Type 8090 Chapter 9. FRU lists 135 136 Chapter 9. FRU lists 137 138 Chapter 9. FRU lists 139 140 Chapter 9. FRU lists 141 Machine Type 8094 142 Chapter 9. FRU lists 143 144 Chapter 9. FRU lists 145 146 Chapter 9. FRU lists 147 Page Chapter 10. Additional Service Information Lenovo 2005, 2008. Portions IBM Corp. 2005. 149 Security features Hardware controlled Passwords Operating system password BIOS levels 150 Flash update procedures This section details how to flash (update) the BIOS. Updating (flashing) BIOS from a diskette or CD-ROM Recovering from a POST/BIOS update failure Power management 152 Automatic configuration and power interface (ACPI) BIOS Automatic Power-On features Recovering software using the Rescue and Recovery program Chapter 10. Additional Service Information 153 Starting the Rescue and Recovery workspace Page Appendix. Notices Lenovo 2005, 2008. Portions IBM Corp. 2005. 155 Television output notice 156 Trademarks

Lenovo Chapter 8. Replacing FRUs

Models: 8086 8087 8088 8089 8090 8094

These precautions and guidelines will help you work safely.

2Microphone connector 4USB connector

© Lenovo 2005, 2008. Portions © IBM Corp. 2005. 89